Kohler 15/30RES User Manual

TP-6198 3/1534 Section 4 Controller
4.5 Faults
4.5.1 Warnings
The fault conditions listed in Figure 4-5 will cause the
controller to display a fault code but will not shut down
the generator set.
Code Fault Description Check
HB High
battery
voltage
warning
Fault code is displayed if the engine starting battery voltage rises
above 16 VDC for a 12 VDC system or above 30 VDC for a 24 VDC
system for more than 10 sec. when the engine is not running. This
fault condition does not inhibit engine starting.
The fault condition clears when the battery voltage returns to a voltage
within the limits for more than 10 sec.
Check the battery rating and
condition. Replace the battery as
needed.
LB Low
battery
voltage
warning
Fault code is displayed if the engine starting battery voltage falls below
9.5 VDC for a 12 VDC system or below 16 VDC for a 24 VDC system
for more than 10 sec. when the engine is not running. This fault
condition does not inhibit engine starting.
The fault condition clears when the battery voltage returns to a voltage
within the limits for more than 10 sec.
Check the battery rating and
condition.
Charge or replace the battery.
Figure 4-5 Fault Warning Codes
4.5.2 Shutdowns
Under the fault conditions listed in Figure 4-6, the
controller displays a fault code and the generator set
shuts down.
Always identify and correct the cause of a fault
shutdown before restarting the generator set. Refer to
Section 3, Troubleshooting, for instructions to identify
and correct the cause of the fault.
Move the generator set master switch to the OFF/
RESET position to r eset the controller after a fault
shutdown. Then move the switch to the AUTO or RUN
position.

Kohler 15/30RES Specifications

General

Brand	Kohler
Model	15/30RES
Category	Portable Generator
Language	English