Home
Mercury
Outboard Motor
8
Mercury 8 User Manual
5
of 1
of 1 rating
126 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
ENGINE INSTALLATION
110
Assemble
steering
link
rod
to
steering
cable
with
flat
washer
and
nylon
insert
locknut.
Tighten
locknut
until
it
seats,
then
back
nut
off
1/4 turn.
Assemble
steering
link rod
to engine
with bolt,
locknut
and
spacer
and flat washers. Torque locknut to specifications.
Remote Wire Harness Connection
1.
Remove
the
cover
and
cable
receptacle
bracket
from
the
bottom cowl.
a
28003
a -
Cover
a
28107
a -
Cable receptacle bracket
117
119
Table of Contents
Table of Contents
5
Warranty Information
9
Transfer of Warranty
9
Warranty Registration United States and Canada
9
Warranty Registration Outside the United States and Canada
10
Fourstroke Outboard Limited Warranty United States, Canada, Europe and Confederation of Independent States
11
Fourstroke Outboard Limited Warranty (Middle-East, and Africa)
14
Year Limited Warranty against Corrosion
17
Warranty Coverage and Exclusions
21
General Information
24
Boater's Responsibilities
24
Before Operating Your Outboard
24
Boat Horsepower Capacity
25
High-Speed and High-Performance Boat Operation
25
Outboard Remote Control Models
25
Remote Steering Notice
26
Lanyard Stop Switch
27
Protecting People in the Water
29
Passenger Safety Message - Pontoon Boats and Deck Boats
30
Wave and Wake Jumping
31
Impact with Underwater Hazards
32
Exhaust Emissions
34
Selecting Accessories for Your Outboard
36
Safe Boating Suggestions
36
Recording Serial Number
38
8/9.9 4-Stroke Specifications - International
38
Component Identification - Standard Models
40
Component Identification - Bigfoot Models
42
Transporting
43
Carrying, Storing and Transporting Your Outboard When Removed from Boat
43
Transporting Portable Fuel Tanks
44
Trailering Boat/Outboard - Models with Power Tilt
45
Trailering Boat/Outboard - Models Without Power Tilt
46
Fuel and Oil
47
Fuel Recommendations
47
Filling Fuel Tank
49
Engine Oil Recommendations
50
Checking Engine Oil
50
Features and Controls
52
Tiller Handle Features
52
Remote Control Features
59
Warning System
60
Power Tilt (if Equipped)
60
Setting the Transom Angle of Your Outboard
62
Adjusting Transom Angle
64
Shallow Water Operation
64
Tilting Outboard
65
Trim Tab Adjustment
66
Operation
68
Pre-Starting Check List
68
Operating in Freezing Temperatures
68
Operating in Salt Water or Polluted Water
68
Operating Outboard as an Auxiliary Engine
69
Pre-Starting Instructions
69
Engine Break-In Procedure
70
Starting the Engine - Tiller Handle Models
70
Starting the Engine - Remote Control Models
73
Starting a Hot Engine
76
Gear Shifting
77
Stopping the Engine
78
Emergency Starting
78
Maintenance
81
Outboard Care
81
EPA Emissions
81
Inspection and Maintenance Schedule
82
Flushing the Cooling System
84
Top Cowl Removal and Installation
86
Battery Inspection
86
Exterior Care
87
Fuel System
87
Steering Link Rod Fasteners
88
Corrosion Control Anode
90
Propeller Replacement
90
Fuse Replacement - Electric Start Models
92
Spark Plug Inspection and Replacement
93
Timing Belt Inspection
94
Changing Engine Oil
95
Lubrication Points
96
Gearcase Lubrication
100
Checking Power Tilt Fluid
102
Submerged Outboard
102
Storage
103
Storage Preparation
103
Protecting External Outboard Components
104
Protecting Internal Engine Components
104
Gearcase
104
Positioning Outboard for Storage
105
Battery Storage
105
Troubleshooting
107
Starter Motor will Not Crank the Engine (Electric Start Models)
107
Engine will Not Start
107
Engine Runs Erratically
108
Performance Loss
108
Battery will Not Hold Charge
108
Owner Service Assistance
109
Local Repair Service
109
Service Away from Home
109
Parts and Accessories Inquiries
109
Service Assistance
109
Mercury Marine Service Offices
110
Engine Installation
112
Boat Horsepower Capacity
112
Start in Gear Protection
112
Selecting Accessories for Your Outboard
112
Installing Outboard
113
Remote Control Installation
115
Steering Link Rod Fasteners
116
Remote Wire Harness Connection
118
Control Cable Installation
120
Battery Installation - Electric Start Models
125
Battery Connections
125
Propeller Installation
125
Other manuals for Mercury 8
Operation And Maintenance Manual
88 pages
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mercury 8 and is the answer not in the manual?
Ask a question
Mercury 8 Specifications
General
Brand
Mercury
Model
8
Category
Outboard Motor
Language
English
Related product manuals
Mercury 8.2 MAG
132 pages
Mercury 2.8 EI 200
118 pages
Mercury 8.1 S Horizon
74 pages
Mercury MerCruiser 8.1S
58 pages
Mercury MerCruiser MIE 8.2L MPI
1027 pages
MerCruiser 8.2 Horizon ECT
83 pages
MerCruiser Horizon 8.2 ECT
94 pages
10/15 Sea Pro/Marathon - 6/8/9.9/10/15 HP
94 pages
Mercury 50
106 pages
Mercury 40
106 pages
Mercury Optimax 115
522 pages
Mercury Four Stroke
16 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
