34 LD Cart Transporter User's Manual 14766-000 Rev H
2.6 î ąBattery Safety
Platform Modifications
If the user or integrator makes any changes to the LD Platform Cart Transporter or cart, it is
their responsibility to ensure that there are no sharp edges, corners, or protrusions.
Note that any change to the platform or cart can lead to loss in safety or functionality. It is the
responsibility of the user or integrator to ensure that all safety features are operational after
modifications.
2.6 Battery Safety
CAUTION: BATTERYî ąDAMAGEî ąRISK
Immediately charge the battery to a full charge upon receipt to avoid the risk of
discharging the battery below a usable state, which would require battery
replacement.
Effective April 1, 2016, IATAî ąregulations require that air-shipped lithium ion batteries
(UNî ą3480, PI 965) must be transported at a state of charge not exceeding 30%. You should
charge the battery completely as soon as you receive it.
NOTE: If the battery was not sent by air, it may be fully-charged.
l
Store batteries upright (in an environment with relative humidity less than 70%) at:
n One month: +5 to 45°C (41 to 113°F)
n One year: 20 to 25°C (68 to 77°F)
l
Never expose the battery to water. If the battery is leaking, submerge it in mineral oil
and contact your local Omron support.
l
In case of a fire, use a type ABC or type BC dry chemical fire extinguisher..
Maintenance
Every six months:
l Inspect battery for damage or leaks
l Place battery on a charger and allow to fully balance (battery shows all solid
LEDs when fully balanced). For more information please refer to Balancing the
Battery on page 139
2.7 Additional Safety Information
Accidental Cart Separation
In the unlikely event that the cart becomes unlatched from the platform while in motion, the
brakes are designed to stop the cart within six feet.
Mobile Robot LDîSafety Guide
Your local Omron support provides other sources for more safety information:
To Next Page
Loading...
Need help?
General
