Onyx RCR User Manual

AVOID MOTOR FAILURE
Always check to make sure
the cable tie around main
motor phase wires is intact
and not missing. Carry spare
ties to keep the wires against
the axle and away from the
spinning rotor..
P RO-TI P
USER MANUAL
V1.0
20 21
OWNER MAINTENANCE
MOTOR PHASE WIRE CABLE TIE AROUND AXLE
Before every ride you need to check and make sure the cable tie is securely tightened
in place around the phase wires at the motor phase wire exit. This will ensure that
your phase wires do not get damaged from the rotor. If you have damaged the wires
you will need to replace the motor or have it professionally rebuilt. In some cases of
minor damage you can just plug in the spare hall sensor plug inside the bike and it will
function as normal. Also periodically check the disc brake rotor mounting screws and
make sure they are securely fastened.
BATTERY
Follow best practices for Li-Ion battery maintenance. There is much debate about
how to keep your battery lasting a long time so do your research and decide what ts
your riding habits best.
CHAIN AND FREEWHEEL
Keep your chain and freewheel lubricated regularly to prevent premature wear, and
clean your chain after a dirty or salty ride.
CHECK YOUR NUTS + BOLTS
With any moving vehicle it is good practice to always check your hardware before you
ride. You can do a visual by doing a full walk around the bike before every ride and you
should do a physical check after every couple rides to make sure nothing is vibrating
loose. Most bikes that encounter rough terraign will need attention more often.
CHECK THE BRAKE FLUID RESIVOUR
The Front brake is hydraulic and require brake uid to opperate. You should always
check to make sure your brake resivour has enough uid in it to opperate properly or
you will eventually lose your ability to stop with the front brake. There is a window on
the side of the resivour that tells you how much uid is left when you look at it level.
If you do not have experience with maintaining hydraulic brakes have a professional
rell or bleed the brakes for you when needed. Never attempt to ride with leaks or
damaged brake lines.
ADJUST THE REAR BRAKE
Besides replacing the brake pads when needed you should adjust the brake cable
when the pads wear down and/or the cable settles during regular use.

Onyx RCR Specifications

General

Brand	Onyx
Model	RCR
Category	Bicycle
Language	English