66
MAINTENANCE
Lubrication Recommendations
Check and lubricate all components at the intervals outlined in the Periodic Maintenance
Chart beginning on page 63, or more often under severe use, such as wet or dusty conditions.
Items not listed in the chart should be lubricated at the general lubrication interval.
Engine Oil
Always check and change the engine oil at the intervals outlined in the Periodic Maintenance
Chart beginning on page 63. Always change the oil filter whenever changing oil.
WARNING! Vehicle operation with insufficient, deteriorated, or contaminated engine oil will cause
accelerated wear and may result in engine seizure, accident, and injury. Always perform the
maintenance procedures as outlined in the Periodic Maintenance Chart.
Oil Recommendations
POLARIS recommends the use of POLARIS PS-4 5W-50 4-Cycle Oil or a similar oil. Refer
to the specifications section beginning on page 94 for capacities. See page 98 for the part
numbers of POLARIS products.
NOTICE: Mixing brands or using a non-recommended oil may cause serious engine damage. Always
use the recommended oil. Never substitute or mix oil brands.
Always check and change the oil at the intervals outlined in the Periodic Maintenance Chart
beginning on page 63. Always use the recommended engine oil.
Item Lube Method
Engine Oil PS-4 5W-50 4-Cycle Oil Add to proper level on dipstick. See page
67.
Brake Fluid DOT 4 Brake Fluid Maintain level between fill lines. See page
80.
Main Gearcase Oil
(Transmission)
AGL Gearcase Lubricant &
Transmission Fluid
See page 69.
Front Gearcase Oil Demand Drive Fluid See pages 69-70.
Front Prop Shaft Yoke U-Joint Grease Locate fittings and grease (3 pumps
maximum).
Front Control Arm Pivot
Bushings All Season Grease or grease
conforming to NLGI No. 2
Grease 3 fittings on each side of the
vehicle.
Rear Control Arm Pivot
Bushings
Grease 4 fittings on each side of the
vehicle.
Rear Stabilizer Bar
Bushings
Grease one fitting on each side of the
vehicle.
To Next Page
Loading...
Need help?
General
