96
11
TROUBLESHOOTING
ENOM00108-0
If you encounter a problem, consult the check list below to determine the cause and to
take the proper action.
An authorized dealer will always be happy to provide any assistance and information.
Engine will not start.
Engine stalls immediately after starting
Defective idling
Poor acceleration
Engine speed is very high causing
high speed ESG to operate.
Engine speed is very low, causing
low speed ESG to operate.
Boat cannot run at high speed.
Engine overheats.
Battery is not charged.
Starter motor will not operate.
Power tilt will not operate.
Warning lamp A "ON"/"Flash"
Warning lamp B "Flash"
Warning lamp C “Flash”
Three warning lamps “Flash”
Warning buzzer “ON”
Possible cause
Fuel and Lubrication Systems
zz Fuel level is low in the tank.
zzzz z zz
Fuel system connection is
incomplete.
zzzz z zz Fuel system sucks air.
zzzz z zz Fuel pipe is twisted.
zzzz z zz Cap vent is closed.
zzzz z zz
Fuel filter, fuel pump or injector is
clogged.
zzzz z zz
Performance of fuel pump or vapor
separator is deteriorated.
zzz zz Low quality fuel is used
z Primer bulb is clogged.
zz z zz z Low quality engine oil is used.
zz
Engine oil quantity excessive
(emissions of white smoke).
z* zz*
Engine oil is lacking (Oil pressure
switch operates).
z* zz*
Oil filter is clogged (Oil pressure
switch operates).
z* zz*
Oil pump is defective (Oil pressure
switch operates).
Electrical System
zzzz z zzzzz z z z z
Defective wiring, ground, wire
disconnected or loosened.
zzzz z zz Use of spark plugs not specified.
zzzz z z Spark plug is contaminated.
zzzz z z No sparks or weak spark.
zzStop switch short-circuited.
zzStop switch lock is not put.
To Next Page
Loading...
Need help?
General
