TOHATSU MFS 25C User Manual

PRE-OPERATING PREPARATIONS 29
6
phase separation to take place. In addition,
internal corrosion may take place during
storage if alcohol has washed protective oil
films from internal components.
ENOW00018-0
Fuel leakage can cause fire or explosion,
potentially leading to severe injury or loss of
life. Every fuel system part should be
checked periodically, and especially after
long term storage, for fuel leak, change of
hardness of rubber, expansion and/or corro-
sion of metals. In case any indication of fuel
leakage or degradation of fuel part is found,
replace relevant part immediately before
continuing operation.
ENOM00043-B
ENOW00019-1
Do not fill the fuel tank over capacity. The
rise of gasoline temperature may cause gas-
oline to expand which, may leak through air
vent screw when it is open. Leaking gasoline
is a dangerous fire hazard.
ENOW00028-A
Consult an authorized dealer for details on
handling gasoline, if necessary.
Gasoline and its vapors are very flammable
and can be explosive.
When carrying a fuel tank containing gaso-
line:
z Close the fuel tank cap and air vent screw
of fuel tank cap, or gasoline vapor will be
emitted through the air vent screw, cre-
ating a fire hazard.
z Do not smoke.
When or before refueling:
z Be sure to remove the static electricity
charged in your body before refueling.
z The sparks due to static electricity may
cause explosion of flammable gasoline.
z Stop the engine, and do not start the
engine during refueling.
z Do not smoke.
z Be careful not to overfill fuel tank. Wipe
up any spilled gasoline immediately.
When or before cleaning the gasoline tank:
z Dismount fuel tank from the boat.
z Place the fuel tank away from every
source of ignition, such as sparks or open
flames.
z Do the work outdoors or in a well venti-
lated area.
z Wipe off gasoline well immediately if
spilled.
After cleaning gasoline tank:
z Wipe off gasoline well immediately if
spilled.
z If the fuel tank is disassembled for clean-
ing, reassemble carefully. Imperfect
assembly may cause a fuel leak, possibly
leading to fire or explosion.
z Dispose aged or contaminated gasoline in
accordance with local regulations.
ENOW00029-A
When opening fuel tank cap, be sure to fol-
low the procedure described below. Fuel
could blast out through the fuel tank cap in
case the cap is loosened by using another
procedure when internal pressure of fuel
tank is raised by heat from sources such as
sun light.
1. Full open the air vent screw on the
fuel tank cap and release internal
pressure.
WARNING
2. Fuel filling
WARNING
WARNING
WARNING

TOHATSU MFS 25C Specifications

General

Brand	TOHATSU
Model	MFS 25C
Category	Outboard Motor
Language	English