19
PROGRAMMED MAINTENANCE
PERIODIC ORDINARY MAINTENANCE CHART
INTERVENTION DAILY PERIODIC
RECOVERY TANK CLEANING •
SUCTION FILTER CLEANING
SOLUTION TANK FILTER CLEANING •
BRUSH CLEANING •
BRUSH DISASSEMBLY AND CLEANING •
SQUEEGEE CLEANING •
FRONT SQUEEGEE RUBBER CHECK •
REAR SQUEEGEE RUBBER CHECK •
SPLASH GUARD RUBBER CHECK •
CHECK SQUEEGEE ADJUSTMENT •
SQUEEGEE HOSE CLEANING •
SOLUTION TANK CLEANING •
CHECK BATTERIES ELECTROLYTE •
RECOMMENDED BRUSHES
Brushes must be chosen depending on type of floor and dirt to be removed.
The employed material and the bristles diameter are the elements that distinguish different types
of brushes.
MATERIAL CHARACTERISTICS
PPL
(Polypropylene)
Good wear resistance. Maintains characteristics with hot water up to 122°F
(50°C). It is not hygroscopic.
NYLON Excellent wear resistance, even with hot water. It is hygroscopic.
TYNEX Nylon bristles with grains of abrasive material. Use with caution in order
not to mark the floor or ruin the polishing.
BRISTLES
THICKNESS
Thicker bristles are more rigid and must be used on smooth floor or
floor with small joints. On irregular floors with deep joints or relieves,
it is recommended to use softer bristles which penetrate more easily
and deeper. Please be aware that when brush bristles are worn out and
therefore too small, they become rigid and unable to penetrate and clean
deeper. This may also happen with thicker bristles creating brush vibration.
PAD HOLDER It is equipped with anchor points which permit the blocking of the abrasive
pad during work. The pad is recommended to clean smooth floors.
CODE QTY DESCRIPTION USE
48902010 1 Brush PPL 0.3 Irregular floors with large joints.
48902020 1 Brush PPL 0.7 Smooth floors with small joints and persistent dirt.
48902030 1 Brush PPL 0.9 Smooth floors with small joints and persistent dirt.
48902040 1 Brush TYNEX Floors of resistant material and particularly dirty.
48902050 1 Brush PPL 0.6 Normal floors.
48902060 1 Brush 5-mix For all types of floors.
48802010 1 Pad holder + center lock
green
For pads of 20”, for smooth surfaces cleaning.
To Next Page
Loading...
Need help?
General