Emerson Fisher FIELDVUE DVC6000 HW2 User Manual

www.Fisher.com
Fisher
™
FIELDVUE
™
DVC6000 HW2 Digital Valve
Controller
This manual applies to
Instrument Level HC, AD, PD, ODV
Device Type 130b
Device Revision 1 & 2
Hardware Revision 2
Firmware Revision 6
DD Revision 4 & 5
Contents
Section 1 Introduction 3.................
Scope of Manual 3..............................
Conventions Used in this Manual 3................
Description 3..................................
Specifications 4................................
Related Documents 7...........................
Educational Services 8...........................
Section 2 Wiring Practices 9..............
Control System Requirements 9..................
HART Filter 9.................................
Voltage Available 9............................
Compliance Voltage 11........................
Auxiliary Terminal Wiring Length Guidelines 12....
Maximum Cable Capacitance 12.................
Installation in Conjunction with a Rosemountt
333 HART Tri‐Loopt HART‐to‐Analog
Signal Converter 17.........................
Section 3 Configuration 19...............
Guided Setup 19...............................
Manual Setup 19...............................
Mode and Protection 20........................
Instrument Mode 20.......................
Write Protection 20........................
Instrument 20................................
Identification 20...........................
Serial Numbers 21.........................
Units 21..................................
Terminal Box 21...........................
Input Range 21............................
Spec Sheet 22.............................
Edit Instrument Time 22....................
Travel/Pressure Control 22......................
Travel/Pressure Select 22...................
Cutoffs and Limits 23.......................
End Point Pressure Control 23................
Pressure Control 24........................
Pressure Fallback 24........................
Control Mode 25..........................
Characterization 25........................
Dynamic Response 27......................
Tuning 28....................................
Travel Tuning 28...........................
Pressure Tuning 31........................
Travel/Pressure Integral Settings 31..........
Valve and Actuator 32..........................
Partial Stroke Test 34..........................
Outputs 37...................................
Output Terminal Configuration 37............
Switch Configuration 37....................
HART Variable Assignments 38..............
Transmitter Output 38.....................
Burst Mode 38............................
Alert Setup 39.................................
Change to HART 5 / HART 7 40....................
Instruction Manual
D103785X012
DVC6000 HW2 Digital Valve Controller
June 2017

Emerson Fisher FIELDVUE DVC6000 HW2 Specifications

General

Brand	Emerson
Model	Fisher FIELDVUE DVC6000 HW2
Category	Controller
Language	English