TECHNICAL DATA 23
165
Spring length 225 mm (8.86 in)
Gas pressure 10 bar (145 psi)
Static sag 37 mm (1.46 in)
Riding sag 110 mm (4.33 in)
Fitted length 415 mm (16.34 in)
Shock absorber fluid ( p. 169) SAE 2.5
23.9 Chassis tightening torques
Remaining screws, chassis EJOT PT
®
K60x25‑Z 2 Nm (1.5 lbf ft)
Screw, fuel pump EJOT PT
®
2.3 Nm (1.7 lbf ft)
Screw, hose clip, inlet sleeve 2.8 Nm (2.07 lbf ft)
Screw, intake air temperature sen-
sor
EJOTDELTA PT
®
45x12-Z 0.7 Nm (0.52 lbf ft)
Screw, oil fill level sensor G 3/4 " 7 Nm (5.2 lbf ft)
Screw, oil pump holder on oil tank EJOTDELTA PT 45x12-Z 0.7 Nm (0.52 lbf ft)
Screw, pressure regulator EJOT PT
®
K60x25‑Z 2.3 Nm (1.7 lbf ft)
Screw, radiator hoses clip 2.4 Nm (1.77 lbf ft)
Nut, throttle cable wire on throttle
valve body
M4 3 Nm (2.2 lbf ft)
Screw, emergency OFF switch (All
EXC models)
M4 0.4 Nm (0.3 lbf ft)
Screw, fixed grip M4 5 Nm (3.7 lbf ft)
Loctite
®
243™
Screw, throttle valve body cover M4 2.6 Nm (1.92 lbf ft)
Spoke nipple, front wheel M4.5 6 Nm (4.4 lbf ft)
Spoke nipple, rear wheel M4.5 6 Nm (4.4 lbf ft)
Remaining nuts, chassis M5 5 Nm (3.7 lbf ft)
Remaining screws, chassis M5 5 Nm (3.7 lbf ft)
Screw, battery terminal M5 2.5 Nm (1.84 lbf ft)
Screw, brake line guide for link
fork
M5 5 Nm (3.7 lbf ft)
Screw, ground wire in tail section M5 5 Nm (3.7 lbf ft)
Screw, light switch (All EXC mod-
els)
M5 1 Nm (0.7 lbf ft)
Screw, shock absorber adjusting
ring
M5 5 Nm (3.7 lbf ft)
Screw, turn signal switch (All
EXC models)
M5 1 Nm (0.7 lbf ft)
Nut, cable on starter motor M6 4 Nm (3 lbf ft)
Remaining nuts, chassis M6 10 Nm (7.4 lbf ft)
Remaining screws, chassis M6 10 Nm (7.4 lbf ft)
Screw, ball joint of push rod on
foot brake cylinder
M6 10 Nm (7.4 lbf ft)
Loctite
®
243™
Screw, battery support bracket M6 6 Nm (4.4 lbf ft)
Screw, brake lever M6 5 Nm (3.7 lbf ft)
Screw, cable on starter relay M6 6 Nm (4.4 lbf ft)
Screw, chain guide M6 10 Nm (7.4 lbf ft)
To Next Page
Loading...
Need help?
General
