Scheppach SG3200 User Manual

 www.scheppach.com /  service@scheppach.com /  +(49)-08223-4002-99 /  +(49)-08223-4002-58
26
|
GB
• Keep the fuel out of the reach of children.
• If there are occasional taps or knocks
from the engine, you should use a di󰀨er-
ent brand of petrol. If this does not solve
the problem, contact an authorised dealer.
WARNING: Operating the engine with
continuous ignition tapping or knocking
can result in damage to the engine. Op-
erating the engine with continuous igni-
tion tapping or knocking is considered
improper use. The manufacturer is not
responsible for the resulting damages;
the user solely bears the risk.
9. Initial operation
Earthing the generator
The power unit is equipped with an earth
that connects the frame structure of the unit
to the earth connections in the a.c. sock-
ets. The earth is not connected to the a.c.
neutral cables. If the power unit is tested
with a phasing tester, it does not have the
same ground loop as a normal household
appliance.
To protect against electric shock, ensure
that the generator is earthed. Connect the
generator and the external earth source,
e.g. a water pipe that is driven into the
earth or a copper pipe that is driven into
the earth, with a thick wire.
WARNING: Do not use any pipes that
carry inammable substances as an
earth source.
Start the engine (Fig. 1 + 2)
NOTE: Do not connect the electrical de-
vice before starting the engine.
1 Turn the fuel valve (16) to ON.
When the engine is cold:
Turn the choke lever (18) to the CLOSED
position.
When the engine is warm:
Turn the choke lever to OPEN
Set the manual choke lever to OPEN.
Checking the oil level (Fig. 7)
Remove the oil ller cap (7) and wipe the
dipstick clean. Check the oil level by insert-
ing the dipstick into the lling nozzle without
screwing the cap on. If the oil level is too
low, rell with the recommended oil up to
the lower rim of the oil lling nozzle.
Oil warning system
The oil warning system is congured to
avoid damage to the engine due to a lack
of oil in the spherical housing. Before the
oil level in the spherical housing can drop
below the safety level, the oil warning sys-
tem automatically cuts the engine o󰀨. If the
oil warning system cuts the engine o󰀨, rell
the engine oil.
Refuelling
Warning! Petrol is highly inammable
and explosive. When handling fuels, you
may su󰀨er burns or other severe inju-
ries. Use petrol with an octane rating of
at least 90 octane. Only use fresh, clean
fuel. Water or impurities in the petrol dam-
age the fuel system.
Tank volume: 15 litres
• Only ll the tank up to the marking in the
fuel strainer. Note that fuel expands.
• Refuel in a well-ventilated area with the
engine stopped. If the engine was in op-
eration immediately before, allow it to cool
rst.
• Never refuel the engine in a building
where the petrol vapour may come into
contact with ames or sparks.
• Do not smoke whilst refuelling or in the
area in which the petrol is stored and pre-
vent naked ames or sparks under these
circumstances.
• After refuelling, ensure that the tank cov-
er is closed correctly and securely again.
Take care!
• Mop up spilled petrol immediately.
• If petrol is spilled, ensure that the area is
dried before starting the engine.
• Avoid repeated or long contact of the fuel
with the skin and avoid breathing in the
fumes.

Scheppach SG3200 Specifications

General

Castor wheels	Yes
Product color	Black, Blue
Frame material	Stainless steel
Number of wheels	2 wheel(s)
Oil tank capacity	15 L
Fuel tank material	Steel
Fuel type	Gasoline
Rated power	2800 W
Engine power	6.5 hp
Rated voltage	230 V
Ignition system	-
Fuel consumption	- l/h
Rated DC voltage	12 V
Fuel tank capacity	- L
Engine displacement	196 cm³

Weight and Dimensions

Depth	590 mm
Width	445 mm
Height	450 mm
Weight	43000 g
Package width	605 mm
Package weight	47000 g