PRE-OPERATING PREPARATIONS20
6
age if alcohol has washed protective oil
films from internal components.
ENOW00018-0
Fuel leakage can cause fire or explosion,
potentially leading to severe injury or loss
of life. Every fuel system part should be
checked periodically, and especially after
long term storage, for fuel leak, change of
hardness of rubber, expansion and/or cor-
rosion of metals. In case any indication of
fuel leakage or degradation of fuel part is
found, replace relevant part immediately
before continuing operation.
ENOM01002-0
ENOW0002A-A
Use of engine oils that do not meet these
requirements will result in reduced engine
life, and other engine problems.
Use a genuine engine oil or recommended
one (TCW3). Refer to your Distributor.
Will not recommend use of other two
stroke engine oil.
Add engine oil into fuel oil tank. The mixing
ratio with gasoline is 50 : 1 (50 parts gaso-
line and one part oil). Mix well by hand. The
mixing ratio during break-in running is 25 :
1.
Mixing Ratio
ENOM01003-A
Engine oil â gasoline mixing
procedure
ENOW00937-0
z Do not use other than two stroke engine
oil with specified grade, or the engine
may be damaged.
z Do not use fuel prepared in other than
specified mixing ratio.
- Lack of engine oil can cause severe
engine trouble such as piston seizure.
- Excess of engine oil can shorten spark
plug life, and/or cause increase of nox-
ious exhaust.
For quantities of engine oil and gasoline to
be pre-mixed, refer to table in previous
page.
î When fuel tank built in the outboard
motors is used for operation:
1
Prepare separate fuel container for pre-
mixing.
2
Pour engine oil into fuel container, and
then, gasoline.
3
Put cap on the container, and close
tightly.
4
Shake the container to mix engine oil
and gasoline well and even.
5
Pour the mixture into fuel tank.
WARNING
2. Engine oil recommendation
CAUTION
Gasoline : Engine Oil
During break-in 25 : 1
After break-in 50 : 1
CAUTION
ENOF01708-0
10L
(10 :0.2)
(10 :0.4)
(25:0.5)
(25:1)
2L 25L 30L
0
0.2L
0.4L
0.5L
1.0L
25 : 1
50 : 1
Oil
Fuel by Oil Mixing (25:1, 50:1)
Gasoline
To Next Page
Loading...
Need help?
General
