To Next Page

To Previous Page

8 ERGONOMICS 67

602626-10

–

Mount the rider footrest with spring

and pin

Pliers for footrest spring (58429083000)

–

Mount washer

and cotter pin

8.9 Foot brake lever

602627-10

Foot brake lever

is located in front of the right footrest.

The rear brake is activated using the foot brake lever.

8.10 Adjusting the basic position of the foot brake lever x

Warning

Danger of accidents Brake system failure.

– If there is no free travel on the foot brake lever, pressure builds up on the rear brake circuit. The rear brake can fail due to over-

heating. Adjust the free travel on foot brake lever according to specifications.

Default Chapter5
- Table of Contents5
1 Means of Representation10
- Symbols Used10
- Formats Used10
2 Safety Advice11
- Use Definition - Intended Use11
- Degrees of Risk and Symbols12
- Tampering Warning12
- Safe Operation13
- Protective Clothing14
- Work Rules14
- Environment14
- Owner's Manual15
3 Important Information16
- Warranty16
- Operating and Auxiliary Substances16
- Spare Parts, Accessories16
- Service16
- Figures17
- Customer Service17
4 View of Vehicle18
- View of Vehicle, Front Left Side (Example)18
- View of Vehicle, Rear Right Side (Example)20
5 Serial Numbers22
- Chassis Number22
- Type Label22
- Key Number23
- Engine Number23
- Fork Part Number24
- Shock Absorber Part Number24
6 Controls26
- Clutch Lever26
- Hand Brake Lever26
- Throttle Grip27
- Switch on the Left Side of the Handlebar27
- Combination Switch27
- Light Switch28
- Hazard Warning Flasher Switch28
- Menu Switch29
- Turn Signal Switch29
- Horn Button30
- Switch on the Right Side of the Handlebar30
- Emergency off Switch30
- Electric Starter Button31
- Ignition/Steering Lock31
- Immobilizer32
- Socket for Electrical Accessories32
- Opening the Filler Cap33
- Closing the Filler Cap34
- Fuel Cocks35
- Opening the Storage Compartment36
- Closing the Storage Compartment36
- Seat Lock37
- Tool Set38
- Grab Handles38
- Luggage Rack Plate39
- Passenger Footrests39
- Shift Lever40
- Side Stand41
- Center Stand (Option: Center Stand)41
7 Combination Instrument42
- Overview42
- Activation and Test42
- Matrix Display43
- Segment Display43
- Indicator Lamps44
- Message on the Matrix Display45
- Shift Warning Light46
- Service Display47
- Matrix Display Menu47
- Favorites47
- Trip 148
- Trip 248
- General Info49
- TPMS" (Optional)49
- Set Favorites50
- Settings50
- Warnings51
- Heat Grip" (Optional)51
- Mtc/Abs52
- Load52
- Damping53
- Drive Mode53
- Menu Overview54
- Language56
- Distance56
- Temp57
- Volume57
- Pressure58
- Clock/Date58
- Fuel Cons59
- Drl59
- Shift Light60
- Quick Shift60
- Heat Grips61
8 Ergonomics62
- Adjusting the Driver's Seat62
- Handlebar Position63
- Adjusting the Handlebar Position63
- Adjusting the Wind Shield64
- Adjusting the Basic Setting of the Clutch Lever66
- Adjusting the Basic Position of the Hand Brake Lever66
- Rider Footrests67
- Adjusting the Footrests67
- Foot Brake Lever69
- Adjusting the Basic Position of the Foot Brake Lever69
- Checking the Basic Position of the Shift Lever71
- Adjusting the Basic Position of the Shift Lever71
9 Preparing for Use73
- Advice on First Use73
- Running in the Engine74
- Loading the Vehicle75
10 Riding Instructions77
- Checks and Maintenance Measures When Preparing for Use77
11 Service Schedule90
- Additional Information90
- Required Work90
- Recommended Work93
12 Suspension Setting94
- Damping" (Option: with EDS)94
- Load" (Option: with EDS)94
- Fork/Shock Absorber95
- Adjusting the Compression Damping of the Fork (Option: Without EDS)95
- Adjusting the Rebound Damping of the Fork (Option: Without EDS)96
- Adjusting the Rebound Damping of the Shock Absorber (Option: Without EDS)97
- Adjusting the Spring Preload of the Shock Absorber (Option: Without EDS)98
- Service Work on the Chassis100
- Raising the Vehicle with the Center Stand (Option: Center Stand)100
- Removing the Vehicle from the Center Stand (Option: Center Stand)100
- Removing the Passenger Seat101
- Mounting the Passenger Seat102
- Removing the Driver's Seat102
- Mounting the Driver's Seat103
- Checking for Chain Dirt103
- Cleaning the Chain104
- Checking the Chain Tension105
- Adjusting the Chain Tension106
- Checking the Chain, Rear Sprocket and Engine Sprocket108
- Checking/Rectifying the Fluid Level of the Hydraulic Clutch111
- Checking the Steering Head Bearing Play112
- Removing the Bottom Triple Clamp Cover113
- Installing the Bottom Triple Clamp Cover113
- Removing the Front Side Cover114
- Installing the Front Side Cover115
- Removing the Mask Spoiler116
- Installing the Mask Spoiler119
- Removing the Front Fender121
- Installing the Front Fender122
- Removing the Tank Cover122
- Installing the Tank Cover124
- Removing the Wind Shield125
- Installing the Wind Shield126
14 Brake System127
- Abs/Antilock Brake System127
- Checking the Brake Discs129
- Checking the Brake Fluid Level of the Front Brake130
- Adding Front Brake Fluid130
- Checking the Front Brake Linings132
- Checking the Rear Brake Fluid Level133
- Adding Rear Brake Fluid134
- Checking the Rear Brake Linings136
15 Wheels, Tires137
- Removing the Front Wheel137
- Installing the Front Wheel139
- Removing the Rear Wheel141
- Installing the Rear Wheel143
- Checking the Rear Hub Rubber Dampers145
- Checking the Tire Condition147
- Checking the Tire Air Pressure148
- Checking Spoke Tension149
16 Electrical System151
- Daytime Running Light151
- Removing the Battery151
- Installing the Battery153
- Recharging the Battery X155
- Changing the Main Fuse159
- Changing the Fuses in the Fuse Box161
- Removing the Headlight Mask with the Headlight164
- Refitting the Headlight Mask with the Headlight165
- Changing the Low Beam Bulb166
- Changing the High Beam Bulb168
- Checking the Headlight Setting170
- Adjusting the Headlight Range170
- Activating/Deactivating the Ignition Key172
17 Cooling System177
- Checking the Coolant Level in the Compensating Tank177
- Correcting the Coolant Level in the Compensating Tank178
18 Engine Tuning180
- Drive Mode180
- Mtc/Motorcycle Traction Control180
19 Service Work on the Engine182
- Checking the Engine Oil Level182
- Changing the Engine Oil and Filter, Cleaning the Oil Screens183
- Adding Engine Oil187
20 Cleaning, Care190
- Cleaning Motorcycle190
- Checks and Maintenance Steps for Winter Operation192
21 Storage193
- Preparing for Use after Storage194
22 Troubleshooting195
23 Technical Data197
- Engine197
- Engine Tightening Torques198
- Capacities201
- Engine Oil201
- Coolant202
- Fuel202
- Chassis202
- Option: with EDS202
- Option: Without EDS202
- Electrical System204
- Option: Without EDS204
- Option: with EDS204
- Tires205
- Fork205
- Option: with EDS205
- Option: Without EDS206
- Shock Absorber207
- Option: with EDS207
- Option: Without EDS207
- Chassis Tightening Torques208
24 Substances212
25 Auxiliary Substances216
26 Standards218
- Index219

Brand	KTM
Model	1190 Adventure EU
Category	Motorcycle
Language	English

KTM 1190 Adventure EU User Manual

Table of Contents

Questions and Answers:

KTM 1190 Adventure EU Specifications

Related product manuals