11 SERVICE WORK ON THE CHASSIS 55
S01241-10
–
Remove screws
5
with the collar bushings.
S01245-10
– Pull both spoilers off the sides of the radiator bracket and lift off the fuel tank.
11.33 Installing the fuel tank
Danger
Fire hazard Fuel is highly flammable.
The fuel in the fuel tank expands when warm and can escape if overfilled.
– Do not refuel the vehicle in the vicinity of open flames or lit cigarettes.
– Switch off the engine for refueling.
– Make sure that no fuel is spilled; particularly not on hot parts of the vehicle.
– If any fuel is spilled, wipe it off immediately.
– Observe the specifications for refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
– Avoid skin, eye and clothing contact with fuel.
– Immediately consult a doctor if you swallow fuel.
– Do not inhale fuel vapors.
– In case of skin contact, rinse the affected area with plenty of water.
– Rinse the eyes thoroughly with water, and consult a doctor in case of fuel contact with the eyes.
– Change your clothing in case of fuel spills on them.
Main work
– Check the throttle cable routing. ( p. 60)
S01241-11
– Position the fuel tank and fit the two spoilers to the sides of the radiator bracket.
– Make sure that no cables or throttle cables are trapped or damaged.
– Attach the hose to the fuel tank breather on the tank lid.
–
Mount and tighten screws
1
with the collar bushings.
Guideline
Remaining screws, chassis M6 10 Nm (7.4 lbf ft)
To Next Page
Loading...
Need help?
General
