Kubota L245 - Wiring Diagrams for Models L185;L245;L295;L305;L345

63 pages

Save Page as PDF

To Previous Page

Wiring Diagrams

KUBOTA

179—Wiring diagram for Models L18^ and L245.

Horn Switch (Option)

F/g. 180—Wiring diagram for Models L29S, L305 and 1.345.

Main Page

Index1
Condensed Service Data3
Front System (Two-Wheel Drive)6
Front Axle6
Tie Rods and Toe-In6
Steering Spindle and Wheel Hub6
Front-Wheel Drive7
Tie Rods and Toe-In/Front Drive Axle7
Removing and Reinstalling the Front Axle Assembly7
Outer Drive Assembly8
R&R and Overhaul8
Cross-Sectional View of Front-Wheel Drive Axle Assembly8
Exploded View of Front Axle Support and Components for Tractors Equipped with Front-Wheel Drive8
Exploded View of Outer Drive Assembly Used on Tractors Equipped with Front-Wheel Drive9
View of Front-Wheel Drive Steering Linkage and Knuckle Pins9
Backlash between Lower Bevel Gear and Axle Bevel Gear9
Differential and Bevel Gear Assembly10
Exploded View of Front-Wheel Drive Differential and Bevel Drive Gear Assembly10
Axial and Play of Axle Shaft10
Bevel Pinion Shaft Bearing Preload10
Rolling Torque of Bevel Pinion Shaft with Differential Assembly Installed11
Exploded View of Two-Place Drive Shaft Assembly with Center Carrier Bearing11
Checking Backlash between Ring Gear and Pinion11
Transfer Case/Idler Gear Assembly View11
Steering System12
Manual Steering12
Transfer Case R&R and Overhaul12
Manual Steering Gear Assembly Exploded View12
Power Steering - Integral Type13
Open Side of Sector Shaft "U"14
"O" Ring Installation14
Side/Upper Cover Seal and Bearing Installation14
View of Ball Nut Seals Correctly Installed/View of Lower Cover Seal Ring and Bearing Installation14
Power Steering - Booster Type15
Steering Pump16
Pressure Test16
Pressure Gage and Flow Control Valve Connected to Check Hydraulic Pump Discharge Pressure16
Hydraulic Pumps Exploded Views17
Engine and Components18
R&R Engine18
Cylinder Head18
Compression Release18
Valves and Seats19
Valve Guides19
Carbon Scraper19
Decompressor Mechanism and Adjustment Point Cross-Sectional View19
Valve Springs/Levers/Timing20
Timing Gear Cover20
View of Governor Linkage and Springs20
View of Timing Gear Marks Correctly Aligned20
Timing Gears21
Camshaft21
Rod and Piston Units21
Mark Top of Piston in Relation to Identification Marks on Connecting Rod Prior to Disassembly21
Piston and Rings22
Piston Pins22
Cylinder Sleeves22
Crankshaft and Main Bearings22
Diesel Fuel System23
Crankshaft Rear Oil Seat23
Oil Pump23
Fuel Filter23
Injection Pump24
Timing to Engine24
Typical Governor Speed Control Components Exploded View24
Injector Nozzles25
Testing and Locating Faulty Nozzle25
Governor and Fuel Camshaft25
Cooling System26
Radiator26
Thermostat26
Water Pump26
Electrical System27
Alternator and Regulator27
Fan Shaft27
Typical Alternator Exploded View28
Checking/Adjusting Regulator Cut-In Voltage28
Insulating Washers29
Continuity Check29
Checking Diodes29
Starter Motors Exploded Views29
Clutch30
Starter Motor and Magnetic Switch30
Measure Clutch Pedal Free Travel at Top of Pedal30
Transmission (Models L185-L245-L285-L295-L305-L345)31
Shifter Rails and Forks31
Dual Plate Clutch31
Single Plate Clutch Assembly Exploded View31
Transmission Shift Rails and Forks Exploded View32
Front Transmission33
Exploded View of Shifter Forks and Shafts33
Exploded View of Gears and Shafts Located in Front Transmission Housing34
Front Transmission Overhaul35
Gears and Shafts Exploded Views35
Rear Transmission Housing36
Transmission (Models L235-L275-L355)38
Shifter Rails and Forks (L235-L275-L355)38
Front Transmission (L235-L275-L355)40
Rear Transmission Housing (L235-L275-L355)42
Shuttle Transmission (Model L355)44
Shuttle Control Valve Test/Adjust/R&R/Overhaul44
Shuttle Control Valve Exploded View45
Hydraulic Shuttle Mainshaft Assembly Exploded View45
Shuttle Gearcase and Reverse Idler Gear Exploded View45
Differential and Bevel Gears46
Shuttle Clutches46
Differential Lock48
Bearing Preload48
Backlash Adjustment48
Typical Gear Tooth Mesh Patterns on Ring Gear48
Final Drive49
Brakes Adjustment/R&R and Overhaul50
Typical Brake Control Linkage Exploded View51
Exploded View of Internal, Wet, Disc Type Brake Assembly51
Exploded View of External, Dry, Drum and Shoe Type Brake Used on Model L28551
Power Take-Off52
PTO Shift Linkage Exploded Views52
Overruning Clutch52
Hydraulic System53
Fluid and Filter53
Troubleshooting53
Hydraulic Pump Drive, Pipes and Hydraulic Filter Exploded Views53
Hydraulic Tests and Adjustments54
Hydraulic System Pressure55
Linkage Adjustment55
Dimensions for Test Bar Used in Draft Control Adjustment55
View of Typical Hydraulic Pump/Position Control Feedback Rod Adjustment55
Pump56
Exploded View of Single Hydraulic Pump56
Exploded View of Front and Rear Hydraulic Pump Sections Used on L345 and L355 Equipped with Power Steering56
Hydraulic Valves57
Relief Valve57
Flow Priority Valve57
View of Hydraulic Valves and Operating Linkage57
Position Control Valve58
Draft Control Valve58
Rockshaft Housing59
Exploded View of Draft Control Valve59
Wiring Diagram for Model L28560
Wiring Diagram for Models L235 and L27561
Wiring Diagram for Model L35562
Wiring Diagrams for Models L185/L245/L295/L305/L34563

Kubota L245 - Wiring Diagrams for Models L185;L245;L295;L305;L345

Table of Contents

Related product manuals