Suzuki DF200 Service Manual

2-2 PERIODIC MAINTENANCE
PERIODIC MAINTENANCE SCHEDULE
The chart below lists the recommended intervals for all the required periodic service work necessary to keep
the motor operating at peak performance and economy.
Maintenance intervals should be judged by number of hours or months, whichever comes first.
NOTE:
More frequent servicing should be performed on outboard motors that are used under severe conditions.
PERIODIC MAINTENANCE CHART
I: Inspect and clean, adjust, lubricate or replace, if necessary T: Tighten R: Replace
NOTE:
OIL CHANGE REMINDER SYSTEM
• Refer to page 3-45 for function and operation.
• See page 2-5 for reset information.
Interval
Initial 20 hrs. or
1 month
Every 50 hrs. or
3 months
Every 100 hrs.
or 6 months
Every 200 hrs.
or 12 months
Item to be serviced
Spark plug —— I R
Fuel line
IIII
Replace every 2 years.
PCV system
IIII
Replace every 2 years.
Engine oil [NOTE] R—R R
Gear oil R—RR
Lubrication —I I I
Anodes & Bonding wires —I I I
Battery —I I I
Fuel mixture check
(O2 feedback)
Perform every 2 years.
Engine oil filter R——R
Low pressure fuel filter
—I I I
Replace every 400 hours or 2 years.
Low pressure fuel pump filter Replace every 1 000 hours.
High pressure fuel filter Replace every 1 000 hours.
Ignition timing ——— I
Idle speed I——I
Tappet clearance I——I
Water pump ——— I
Water pump impeller ——— R
Propeller nut & pin I—I I
Bolt & Nuts T—T T
34

Suzuki DF200 Specifications

General

Brand	Suzuki
Model	DF200
Category	Outboard Motor
Language	English