Trane Sintesis RTAF HE series User Manual

RLC-SVX19G-GB
81
11UNT-PRC002-GB
Sound power levels
Discharge
Measurement conditions:
Measurements taken in a room adjacent to the room containing the FWD, at the outlet of the rectangular duct (1.5 m
long) fixed to its discharge opening.
Fan Power level in dB(A), per Hz frequency band Overall power
Unit speed 125 250 500 1000 2000 4000 8000 dB(A)
1 55 50 42 37 37 31 30 46
FWD 08 2 57 54 47 40 30 38 40 50
3 58 57 50 42 32 40 43 53
1 57 51 45 42 34 33 28 48
FWD 10 2 58 54 48 45 38 39 35 51
3 60 58 50 48 40 42 39 54
1 57 51 45 42 34 33 28 48
FWD 12 2 58 54 48 45 38 39 35 51
3 60 58 50 48 40 42 39 54
1 56 62 50 48 39 38 36 56
FWD 14 2 61 66 55 53 47 46 45 60
3 63 69 58 56 50 50 49 63
1 57 63 51 49 40 39 37 57
FWD 20 2 61 66 55 53 47 46 45 60
3 63 69 58 56 50 50 49 63
Intake
Measurement conditions:
Measurements taken at the horizontal air intake.
Fan Power level in dB(A), per Hz frequency band Overall power
Unit speed 125 250 500 1000 2000 4000 8000 dB(A)
1 56 55 55 53 46 45 42 57
FWD 08 2 63 62 60 60 53 53 53 64
3 66 65 63 62 56 55 57 67
1 62 58 55 58 51 48 44 61
FWD 10 2 66 63 60 62 56 55 52 66
3 70 67 63 65 59 59 57 69
1 62 58 55 58 51 48 44 61
FWD 12 2 66 63 60 62 56 55 52 66
3 70 67 63 65 59 59 57 69
1 66 65 65 65 57 50 46 68
FWD 14 2 73 72 69 71 64 59 57 74
3 78 76 73 75 69 64 63 78
1 68 72 64 64 56 52 50 69
FWD 20 2 76 76 68 71 65 61 61 75
3 78 79 71 74 69 66 66 78
General Data
Table 20a – General Data RTAF 250-410 High Seasonal Efficiency Short - Standard and Low Noise - R134a - R513A
RTAF RTAF RTAF RTAF RTAF RTAF
250 280 310 350 380 410
HSS SN LN HSS SN LN HSS SN LN HSS SN LN HSS SN LN HSS SN LN
Cooling Capacity (1) (kW) 862 968 1066 1195 1312 1432
Unit electrical data (2) (3) (5)
Maximum Power input in cooling (kW) 375 425 471 527 577 627
Unit rated amps (Max compr +Fan+Control) (A) 588 668 739 836 920 997
Unit start up amps (Starting Amps of the largest
compr+RLA of 2nd compr+RLA of all fans+ control)
(A) 741 782 853 989 1034 1111
Unit Power factor 0.92 0.92 0.92 0.91 0.91 0.91
Max power cable cross section (mm²) 4*300 4*300 4*300 4*300 4*300 4*300
Disconnect switch size (A) 1250 1250 1250 1250 1250 1250
Compressor
Quantity # 3 3 3 4 4 4
Type Screw Screw Screw Screw Screw Screw
Model (9) 85-85/70 85-100/85 100-100/100 85-85/85-85
85-100/
85-100
100-100/
100-100
Max Compr Power input Circuit 1/Circuit 2 kW 124-121/101 124-144/124 147-144/147
124-121/
124-121
124-144/
121-144
147-144/
147-144
Max Amps Circuit 1 / Circuit 2 (3) (4) (A) 188-201/153 188-240/188 224-240/224
188-201/
188-201
188-240/
188-240
238-240/
238-240
Start up Amps Circuit 1 / Circuit 2 (3) (4) (A) 188-354/153 188-354/188 224-354/224
188-354/
188-354
188-354/
188-354
224-354/
224-354
Motor RPM (rpm) 3000 3000 3000 3000 3000 3000
Oil sump heater Circuit 1 / Circuit 2 (W) 300/150 300/150 300/150 300/300 300/300 300/300
Evaporator
Quantity # 1 1 1 1 1 1
Type Flooded shell and tube heat exchanger
Evaporator model 300D 300B 300A 500D 500C 500B
Evaporator Water Content volume (l) 97 108 120 146 159 170
Antifreeze Heater (W) 2240 2240 2240 2440 2440 2440
One pass evaporator
Evap. Water Flow rate - Minimum (l/s) 17.7 20.1 22.8 25.0 27.8 30.3
Evap. Water Flow rate - Maximum (6) (l/s) 65.8 74.5 84.8 92.8 103.0 112.5
Nominal water connection size (Grooved coupling)
(in) -
(DN)
6" - 150 6" - 150 6" - 150 8" - 200 8" - 200 8" - 200
One pass with turbulator evaporator
Evap. Water Flow rate - Minimum (6) (l/s) 14.8 16.7 19.0 20.8 23.1 25.3
Evap. Water Flow rate - Maximum (l/s) 59.1 66.9 76.1 83.4 92.5 101.1
Nominal water connection size (Grooved coupling)
(in) -
(mm)
6" - 150 6" - 150 6" - 150 8" - 200 8" - 200 8" - 200
Hydraulic Module Components
Standard head pressure pump option
Available Head Pressure (1) (kPa) 167 118 95 146 134 120
Max Motor Power input (kW) 15 15 15 22 22 22
Max Amps (A) 28 28 28 39.7 39.7 39.7
High head pressure pump option
Available Head Pressure (1) (kPa) 223 229 193 N/A N/A N/A
Max Motor Power input (kW) 18.5 22 22 N/A N/A N/A
Max Amps (A) 34.5 39.7 39.7 N/A N/A N/A
Expansion Tank Volume (l) 80 160 160 160 160 160
Max User water loop Volume for factory mounted expansion
tank (1)
(l) 4000 8000 8000 8000 8000 8000
Max. Water-side Operating Pressure without pump package (kPa) 1000 1000 1000 1000 1000 1000
Max. Water-side Operating Pressure with pump package (kPa) 450 450 450 450 450 450
Antifreeze Heater with pump package (W) 3300 3400 3400 3600 3600 3600
Condenser
Type Full aluminum Micro channel heat exchanger
Quantity # 10/4 10/6 10/6 10/8 10/10 12/10
Face area per coil (m²) 2.4 2.4 2.4 2.4 2.4 2.4
Condenser Fan
Quantity # 10/4 10/6 10/6 10/8 10/10 12/10
Diameter (mm) 800 800 800 800 800 800

Trane Sintesis RTAF HE series Specifications

General

Brand	Trane
Model	Sintesis RTAF HE series
Category	Chiller
Language	English