Trane Sintesis RTAF HE series User Manual

RLC-SVX19G-GB
93
11UNT-PRC002-GB
Sound power levels
Discharge
Measurement conditions:
Measurements taken in a room adjacent to the room containing the FWD, at the outlet of the rectangular duct (1.5 m
long) fixed to its discharge opening.
Fan Power level in dB(A), per Hz frequency band Overall power
Unit speed 125 250 500 1000 2000 4000 8000 dB(A)
1 55 50 42 37 37 31 30 46
FWD 08 2 57 54 47 40 30 38 40 50
3 58 57 50 42 32 40 43 53
1 57 51 45 42 34 33 28 48
FWD 10 2 58 54 48 45 38 39 35 51
3 60 58 50 48 40 42 39 54
1 57 51 45 42 34 33 28 48
FWD 12 2 58 54 48 45 38 39 35 51
3 60 58 50 48 40 42 39 54
1 56 62 50 48 39 38 36 56
FWD 14 2 61 66 55 53 47 46 45 60
3 63 69 58 56 50 50 49 63
1 57 63 51 49 40 39 37 57
FWD 20 2 61 66 55 53 47 46 45 60
3 63 69 58 56 50 50 49 63
Intake
Measurement conditions:
Measurements taken at the horizontal air intake.
Fan Power level in dB(A), per Hz frequency band Overall power
Unit speed 125 250 500 1000 2000 4000 8000 dB(A)
1 56 55 55 53 46 45 42 57
FWD 08 2 63 62 60 60 53 53 53 64
3 66 65 63 62 56 55 57 67
1 62 58 55 58 51 48 44 61
FWD 10 2 66 63 60 62 56 55 52 66
3 70 67 63 65 59 59 57 69
1 62 58 55 58 51 48 44 61
FWD 12 2 66 63 60 62 56 55 52 66
3 70 67 63 65 59 59 57 69
1 66 65 65 65 57 50 46 68
FWD 14 2 73 72 69 71 64 59 57 74
3 78 76 73 75 69 64 63 78
1 68 72 64 64 56 52 50 69
FWD 20 2 76 76 68 71 65 61 61 75
3 78 79 71 74 69 66 66 78
General Data
Table 23a – General Data RTAF 250-550 High Seasonal Efficiency - Extra Low Noise - R134a - R513A
RTAF RTAF RTAF RTAF RTAF RTAF RTAF RTAF RTAF RTAF RTAF
250 280 310 350 370 380 400 410 450 510 550
HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN HSE XLN
Cooling Capacity (1) (kW) 879 997 1115 1243 1404 1354 1504 1463 1591 1810 1911
Unit electrical data (2) (3) (4)
Maximum Power input in cooling (kW) 379 429 491 535 641 585 641 631 651 813 813
Unit rated amps (Max compr
+Fan+Control)
(A) 594 674 769 848 999 932 999 1003 1035 1287 1288
Unit start up amps (Starting Amps
of the largest compr+RLA of 2nd
compr+RLA of all fans+ control)
(A) 747 788 883 1001 1081 1046 1081 1117 1149 1369 1370
Displacement Power Factor (DPF) 0.92 0.92 0.92 0.91 0.93 0.91 0.93 0.91 0.91 0.91 0.91
Max power cable cross section (mm
2
) 4x185 4x185 4x185 4x185 4x185 4x185 4x185 4x185 6x185 6x185 6x185
Disconnect switch size (A) 1250 1250 1250 1250 1250 1250 1250 1250 1600 1600 1600
Compressor
Quantity # 3 3 3 4 3 4 3 4 4 4 4
Type Screw Screw Screw Screw Screw Screw Screw Screw Screw Screw Screw
Model (8)
85-85/
70
85-100/
85
100-100/
100
85-85/
85-85
140-115/
140
85-100/
85-100
160-115/
160
100-100/
100-100
120-100/
120-100
140-115/
140-115
160-115/
160-115
Max Compr Power input
Circuit 1/Circuit 2
kW
124-121/
101
124-144/
124
147-144/
147
124-121/
124-121
218-164/
218
124-144/
124-144
218-164/
218
147-144/
147-144
157-144/
157-144
218-164/
218-164
218-164/
218-164
Max Amps Circuit 1 / Circuit 2 (3) (4) (A)
188-201/
153
188-240/
188
224-240/
224
188-201/
188-201
331-273/
331
188-240/
188-240
331-273/
331
224-240/
224-240
238-240/
238-240
331-273/
331-273
331-273/
331-273
Start up Amps Circuit 1 / Circuit 2
(3) (4)
(A)
188-354/
153
188-354/
188
224-354/
224
188-354/
188-354
331-354/
331
188-354/
188-354
331-354/
331
224-354/
224-354
238-354/
238-354
331-354/
331-354
331-354/
331-354
Motor RPM (rpm) 3000 3000 3000 3000 3600 3000 4200 3000 3000 3600 4200
Oil sump heater Circuit 1 / Circuit 2 (W) 300/150 300/150 300/150 300/300 300/300 300/300 300/300 300/300 300/300 300/300 300/300
Evaporator
Quantity # 1 1 1 1 1 1 1 1 1 1 1
Type Flooded shell and tube heat exchanger
Evaporator model 300D 300B 300A 500D 300A 500C 300A 500B 500B 500N 500N
Evaporator Water Content volume (l) 97 108 120 146 120 159 120 170 170 188 188
Antifreeze Heater (W) 2240 2240 2240 2440 2440 2440 2440 2440 2440 2440 2440
Two pass evaporator
Evap. Water Flow rate - Minimum (l/s) 17.7 20.1 22.8 25.0 22.8 27.8 22.8 30.3 30.3 30.3 30.3
Evap. Water Flow rate - Maximum (5) (l/s) 65.8 74.5 84.8 92.8 84.8 103.0 84.8
112.5 112.5 112.5 112.5
Nominal water connection size
(Grooved coupling)
(in) -
(DN)
6" - 150 6" - 150 6" - 150 8" - 200 6" - 150 8" - 200 6" - 150 8" - 200 8" - 200 8" - 200 8" - 200
Two pass evaporator with turbulator
Evap. Water Flow rate - Minimum (5) (l/s) 14.8 16.7 19.0 20.8 19.0 23.1 19.0 25.3 25.3 25.3 25.3
Evap. Water Flow rate - Maximum (l/s) 59.1 66.9 76.1 83.4 76.1 92.5 76.1 101.1 101.1 101.1 101.1
Nominal water connection size
(Grooved coupling)
(in) -
(mm)
6" - 150 6" - 150 6" - 150 8" - 200 6" - 150 8" - 200 6" - 150 8" - 200 8" - 200 8" - 200 8" - 200
Hydraulic Module Components
Standard head pressure pump option (Twin pump)
Available Head Pressure (1) (kPa) 160 106 115 139 NA 127 NA 116 100 NA NA
Max Motor Power input (kW) 15 15 15 22 NA 22 NA 22 30 NA NA
Max Amps (A) 28 28 28 39.7 NA 39.7 NA 39.7 54.1 NA NA
High head pressure pump option (Twin Pump)
Available Head Pressure (1) (kPa) 216 220 174 NA NA NA NA NA NA NA NA
Max Motor Power input (kW) 18.5 22 22 NA NA NA NA NA NA NA NA
Max Amps (A) 34.5 39.7 39.7 NA NA NA NA NA NA NA NA
Expansion Tank Volume (l) 80 160 160 160 NA 160 NA 160 160 NA NA
Max User water loop Volume for
factory mounted expansion tank (1)
(l) 4000 8000 8000 8000 NA 8000 NA 8000 8000 NA NA
Max. Water-side Operating Pressure
without pump package
(kPa) 1000 1000 1000 1000 NA 1000 NA 1000 1000 NA NA
Max. Water-side Operating Pressure
with pump package
(kPa) 450 450 450 450 NA 450 NA 450 450 NA NA
Antifreeze Heater with pump package (W) 3300 3400 3400 3600 3400 3600 3400 3600 3600 3600 3600
Condenser
Type Full aluminum Micro channel heat exchanger
Quantity # 12/4 12/6 14/6 12/10 12/8 12/12 12/8 12/12 12/12 12/12 12/12
Face area per coil (m²) 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4 2.4
Condenser Fan
Quantity # 12/4 12/6 14/6 12/10 12/8 12/12 12/8 12/12 12/12 12/12 12/12
Diameter (mm) 800 800 800 800 800 800 800 800 800 800 800

Trane Sintesis RTAF HE series Specifications

General

Brand	Trane
Model	Sintesis RTAF HE series
Category	Chiller
Language	English