MAINTENANCE SCHEDULE
WARNING! Before you start to do any maintenance work, read the “Maintenance” chap-
ter carefully. This contains instructions for doing work in a safe and correct manner.
IMPORTANT! When both operation and calendar time are specified, do the maintenance
job at the interval which is reached first. Maintenance points marked must be done
by an authorised Volvo Penta workshop.
Daily, before first start
● Engine and engine bay. General inspection ....................................................page 42
● Air filter indicator. Inspection
1)
.......................................................................page 43
● Engine oil. Check level ..................................................................................page 46
● Coolant. Check level ......................................................................................page 51
● Reverse gear. Check oil level (after starting) ..................................................page 71
1)
Change the air filter every 12 months.
After the first 50 hours
● Reverse gear. Oil change/Clean the oil strainer ...................................... page 71/72
● Reverse gear (ZF). Filter change .................................................................. page 72
Every 50 hours / at least every 12 months
● Fuel filter. Drain water/contamination ........................................................... page 60
● Reverse gear (Twin Disc). Seal. Lubrication ................................................. page 72
Every 50-400 hours / at least every 12 months
● Engine oil Change
1)
.......................................................................................page 46
● Oil filter / Bypass filter. Change
2)
..................................................................page 48
1)
Oil change intervals vary, depending on oil grade and sulphur content of the fuel. Please refer to page 45.
2)
Change the filters during each oil change.
Every 200 hours / at least every 6 months
● Reverse gear (ZF). Clean the oil strainer ...................................................... page 71
Maintenance schedule
General information
Your Volvo Penta engine and its equipment are designed for high reliability and long life. They are built to with-
stand a marine environment, but also to have the smallest possible environmental impact. If given preventive
maintenance, according to the maintenance schedule, and if Volvo Penta original spares are used, these qualities
are retained and unnecessary malfunctions can be avoided.
Warranty inspection
During the first period of operation, the specified warranty inspection “First service inspection” must be done by an
authorised Volvo Penta workshop. Instructions about when and where this should be done are found in the
Warranty and service book.
To Next Page
Loading...
Need help?
General
