53
Maintenance schedule
Every 250 hours / at least every 12 months
● Fuel pre-filter (twin filter). Inspection
1)
............................................................... page 74
1)
Only applies to the double filter: Check the pressure gauge and change the filter as
necessary every 1000 hours of operation, or at least once every 12 months.
Every 500 hours / at least every 12 months
● Crankcase ventilation. Change filter ................................................................... page 55
● Drive belts. Inspection/adjustment ...................................................................... page 56
● Coolant (corrosion protection mixture). Topping up
1)
........................................ page 63
● Seawater pump. Check/change the impeller ...................................................... page 68
● Batteries. Checking the electrolyte ..................................................................... page 77
1)
Top up with ½ litre corrosion protection fluid. IMPORTANT! This only applies if the
cooling system is filled with a corrosion protection mixture (not a glycol mixture).
Every 1000 hours / at least every 12 months
Valve clearance. Inspection/adjustment...........................................................not shown
● Coolant filter. Change
1)
..................................................................................... page 65
Clean the insert in the heat exchanger and in the reverse gear oil cooler ......not shown
● Seawater filter. Checking/cleaning
2)
.................................................................. page 68
● Fuel pre-filter. Change filter insert ..................................................................... page 74
● Fuel fine filter. Changing. Venting the fuel system .............................................. page 70
● Reverse gear. Oil strainer. Cleaning ................................................................... page 81
● Reverse gear. Oil. Change .................................................................................. page 82
1)
Not at same time as coolant change.
2)
Adjust the time by experience, after a period of operation.
Every 2000 hours
Turbocharger. Inspection ................................................................................. not shown
Every 12 months
EVC system. Inspection with diagnosis tool .................................................... not shown
Engine and reverse gear. General inspection ..................................................not shown
● Air filter insert. Change ..................................................................................... page 55
● Flushing/Bilge pump. Check the impeller ........................................................not shown
● Engine and reverse gear. Cleaning/painting .................................................... not shown
Every 24 months
Cooling system Inspection/cleaning ................................................................ not shown
Coolant. Change ................................................................................................. page 62
To Next Page
Loading...
Need help?
General
