84
Laying up/Launching
The boat must be laid up to prevent damage to the engine and other equipment if the boat is not used for two
months or more. It is important that this is done in the correct manner, and nothing is forgotten. For this reason,
we have compiled a check list of the most important points.
Before the boat is taken out of service for a long period of time, an authorised Volvo Penta workshop should over
the engine and other equipment. Have any faults and deficiencies attended to, so that the equipment is in order,
ready for the next start.
WARNING! Before you start to do any maintenance work, read the “Maintenance” chapter carefully. This
contains instructions for doing work in a safe and correct manner.
Some conservation oils are flammable. Some are also dangerous to breathe. Ensure good ventilation. Use
a face mask when spraying.
IMPORTANT! Observe the following when cleaning with a high pressure washer: Never aim the water jet at
seals, rubber hoses or electrical components. Never use a high pressure washer for engine cleaning.
Inhibiting
● Warm the engine up to normal operating tem-
perature and check that the oil level in the reverse
gear reaches the MAX mark on the dipstick. Stop
the engine.
● Max 8 month’s stoppage:
Change the oil and oil filter on the engine, then
warm it up afterwards.
● More than 8 month’s stoppage:
Conserve the lubrication and fuel systems with
conservation oil.Please refer to the instruction
on the next page.
● Check that the coolant offers sufficient frost pro-
tection. Top up as necessary. Alternatively, you
can drain the coolant (also drain the coolant fil-
ter).
● Close the sea cock and drain the water from the
seawater system.
● Remove the impeller from the seawater pump.
Store the impeller in a sealed plastic bag, in a
cool place.
● Drain any water and contamination from the fuel
filters and fuel tank. Fill the fuel tank completely,
to avoid condensation.
● Disconnect the battery cables, clean and charge
the batteries. Trickle charge the batteries while
the boat is laid up. A poorly charged battery
can freeze and burst.
● Clean the outside of the battery. Do not use a
high pressure washer for engine cleaning. Touch
up paint damage with Volvo Penta original paint.
● Spray the components of the electrical system
with water-repellent spray (Volvo Penta universal
oil).
● Check and rust-proof any control cables.
● Put a note on the engine with the date, type of
conservation and the conservation oil used.
● Cover over the engine air inlet, exhaust opening
and engine if necessary.
To Next Page
Loading...
Need help?
General
