52
MAINTENANCE SCHEDULE
WARNING! Before you start to do any maintenance work, read the “Maintenance”
chapter carefully. This contains instructions for doing work in a safe and correct man-
ner.
IMPORTANT! When both operation and calendar time are specified, do the mainte-
nance job at the interval which is reached first. Maintenance points marked must
be done by an authorised Volvo Penta workshop.
Daily, before first start
● Engine and engine bay. General inspection .................................................. page 54
● Air filter indicator. Inspection
1)
...................................................................... page 55
● Engine oil. Check level ................................................................................... page 58
● Coolant. Check level ...................................................................................... page 63
● Fuel filter. Drain water/contamination ........................................................... page 71
● Reverse gear. Check oil level (after starting) ................................................. page 81
1)
Change the air filter every 12 months.
After the first 50 hours
● Reverse gear. Oil strainer. Cleaning ............................................................. page 81
● Reverse gear. Oil. Change ............................................................................ page 82
Every 50 hours / at least every 12 months
● Reverse gear. Seal. Lubrication.................................................................... page 82
● Disengageable clutch. Lubrication
1)
............................................................ page 83
Every 50-500 hours / at least every 12 months
● Engine oil Change
2)
..................................................................................... page 58
● Oil filter / Bypass filter. Change
3)
.................................................................. page 60
1)
Applies to release bearing when operated more than 15 times a day. Otherwise, every 500 operating hours.
2)
Oil change intervals vary, depending on oil grade and sulphur content of the fuel. Please refer to page 57.
3)
Change the filters during each oil change.
Maintenance schedule
General information
Your Volvo Penta engine and its equipment are designed for high reliability and long life. They are built to
withstand a marine environment, but also to have the smallest possible environmental impact. If given preventive
maintenance, according to the maintenance schedule, and if Volvo Penta original spares are used, these quali-
ties are retained and unnecessary malfunctions can be avoided.
Warranty inspection
During the first period of operation, the specified warranty inspection “First service inspection” must be done by
an authorised Volvo Penta workshop. Instructions about when and where this should be done are found in the
Warranty and service book.
To Next Page
Loading...
Need help?
General
