CTP Combitherm
MN-35948
•
Rev 16
•
10/18
•
Combitherm® CT PROformance™ Series Operator’s Manual
•
63
Preventative Maintenance
In addition to the routine cleaning and maintenance
procedures, there are several additional steps to be
taken for both sanitation and to keep the oven running
e ciently. Refer to the following inspection checklists
for a comprehensive approach to longevity and
equipment e ciency. These additional safeguards will
help prevent down time and costly repairs.
Do not dispose of grease, fat, wood chips or solid waste
down the oven drain.
Fats and solids will eventually coagulate in the drain
system, causing blockage. Consequently, water
will back-up into the condenser and interior oven
compartment, resulting in an oven that is inoperable.
Make certain the drain screen is always in place.
Remove any solid waste material from the oven
bottom and drain screen before it enters the drain
system.
The routine removal of solids from the drain screen will
help prevent blockage.
Use the authorized combitherm oven cleaner only.
The use of unauthorized cleaning agents may discolor or
harm the interior surfaces of the oven.
To prolong the life of the door gasket, clean this
itemdaily.
The acids and related compounds found in fat,
particularly chicken fat, will weaken the composition of
the gasket unless cleaned on a daily basis. Wipe with a
hot, soapy cloth.
To additionally protect gasket life, allow oven door to
remain slightly open at the end of the production day.
An open door will relieve the pressure on the door gasket.
Routinely clean door hinges.
Open oven door to relieve tension. Clean all parts of
thehinge.
On a monthly basis, decalcify or
descale theoven.
Using the Scale Free cleaner,
CE-27889, place 7 ounces of
the product in the drain. Run a
heavy-duty cleaning cycle. A er
the cleaning cycle has been
completed, use the hand shower
to spray down the oven interior.
Swing open the interior fan guard
and spray down the area behind
the panel. Direct a stream of
water down the interior drain
cover to thoroughly rinse the
cleaner out of the oven. A er the
oven interior has been sprayed
down, run a rinse cleaning cycle.
WARNING
When smoking is completed, remove the smoker
box. Dispose of wood chips in a fire proof waste
receptacle to prevent the risk of fire.
To prevent serious personal injury, death, or
property damage:
Do not steam clean, hose down or flood the
interior or exterior with water or liquid solution
of any kind. Do not use water jet toclean. Failure
to observe this precaution will void the warranty.
Preventative Maintenance
To Next Page
Loading...
Need help?
General
