Grant Vortex Series User Manual

GRANT ENGINEERING (UK) LIMITED
Hopton House, Hopton Industrial Estate, Devizes, Wiltshire, SN10 2EU
Tel: +44 (0)1380 736920 Fax: +44 (0)1380 736991
Email: info@grantuk.com www.grantuk.com
This manual is accurate at the date of printing but will be superseded and should be disregarded if specications and/or appearances are changed in the interests of continued product improve-
ment. However, no responsibility of any kind for any injury, death, loss, damage or delay however caused resulting from the use of this manual can be accepted by Grant Engineering (UK)
Limited, the author or others involved in its publication.
All good sold are subject to our o󰀩cial Conditions of Sale, a copy of which may be obtained on application.
© Grant Engineering (UK) Limited. No part of this manual may be reproduced by any means without prior written consent.
IMPORTANT NOTE FOR INSTALLERS
These instructions are intended to guide installers on the
installation, commissioning and servicing of the Grant Vortex oil
boiler. After installing the boiler, leave these instructions with the
user.
A user handbook is available to guide users in the operation of the
oil boiler.
SPECIAL TEXT FORMATS
The following special text formats are used in these instructions
for the purposes listed below:
! WARNING !
Warning of possible human injury as a consequence of not
following the instructions in the warning.
! CAUTION !
Caution concerning likely damage to equipment or tools
as a consequence of not following the instructions in the
caution.
! NOTE !
Used for emphasis or information not directly concerned
with the surrounding text but of importance to the reader.
PRODUCT CODES AND SERIAL
NUMBERS COVERED
The serial numbers used on Grant oil boilers consist of a fteen
digit numerical code with the nal three digits being the product
identier.
For example:
100000200218743
These instructions cover the following product codes and serial
numbers:
Product code Serial number identier
VTXOMCOMBI21 743
VTXOMCOMBI26 744
VTXOMCOMBI36 745
Page 2
SERVICING
The boiler should be serviced at least every twelve months and
the details entered in the Service Log in the user handbook.
FUEL TYPE
All Grant Vortex boilers are suitable for use with Class C2
Kerosene. To use Bio-Kerosene (B30K), refer to the information
below:
OPERATION ON BIO-FUEL
All Grant Vortex condensing boilers manufactured since May 2011
are suitable for operation on both standard Kerosene (Class C2 to
BS 2869) and also bio-kerosene - up to a 30% blend (B30K).
All burner settings and nozzle sizes (as detailed in Section 2.2 of
these instructions) are correct for both standard kerosene and bio-
kerosene (B30K).
In order to operate this boiler on bio-kerosene, it will be necessary
to take the following actions:
• Use a bio-kerosene (B30K) compatible exible oil line in
place of the oil line supplied with the boiler.
• Have the oil storage tank and oil supply line (including all
pipework, sight gauges, lters, isolating valves, re valves,
de-aeration devices, etc.) checked for their compatibility with
bio-kerosene (B30K).
Where necessary, some or all of these items may have to be
replaced with a bio-kerosene compatible alternative.
• Check the suitability of the ue system with Grant UK.
• Use only bio-kerosene (B30K) that conforms to OPS24.
IMPORTANT:
Under no circumstances, should the boiler be used with
bio-kerosene without the above actions being taken rst.
! NOTE !
This appliance can be used by children
aged from 8 years and above and persons
with reduced physical, sensory or mental
capabilities or lack of experience and
knowledge if they have been given
supervision or instruction concerning
use of the appliance in a safe way and
understand the hazards involved.
Children shall not play with the appliance.
Cleaning and user maintenance shall not
be made by children without supervision.

Grant Vortex Series Specifications

General

Brand	Grant
Model	Vortex Series
Category	Boiler
Language	English