To Next Page

To Previous Page

8 ERGONOMICS 73

S00251-10

–

Mount the rider footrest with spring

and pin

Pliers for footrest spring (58429083000)

–

Mount washer

and cotter pin

8.8 Foot brake lever

S00233-10

Foot brake lever

is located in front of the right footrest.

The rear brake is activated using the foot brake lever.

8.9 Adjusting the basic position of the foot brake lever x

Warning

Danger of accidents Brake system failure.

– If there is no free travel on the foot brake lever, pressure builds up on the rear brake circuit. The rear brake can fail due to over-

heating. Adjust the free travel on foot brake lever according to specifications.

Default Chapter5
- Table of Contents5
1 Means of Representation10
- Symbols Used10
- Formats Used10
2 Safety Advice11
- Use Definition - Intended Use11
- Degrees of Risk and Symbols12
- Overview of Labels14
- Reporting Safety Defects19
- Noise Emission Warranty19
- Operating Noise Warning20
- Consumer Rights20
- Tampering Warning20
- Safe Operation21
- Protective Clothing22
- Work Rules22
- Environment22
- Owner's Manual23
3 Important Information24
- Warranty24
- Operating and Auxiliary Substances24
- Spare Parts, Accessories24
- Service24
- Figures25
- Customer Service25
4 View of Vehicle26
- View of Vehicle, Front Left Side (Vehicle Differs Slightly from Photo)26
- View of Vehicle, Rear Right Side (Vehicle Differs Slightly from Photo)28
5 Serial Numbers30
- Chassis Number30
- Type Label30
- Key Number31
- Engine Number32
- Fork Part Number32
- Shock Absorber Part Number33
6 Controls34
- Clutch Lever34
- Hand Brake Lever34
- Throttle Grip35
- Switch on the Left Side of the Handlebar35
- Combination Switch35
- Light Switch36
- Hazard Warning Flasher Switch36
- Menu Switch37
- Turn Signal Switch37
- Horn Button38
- Switch on the Right Side of the Handlebar38
- Emergency off Switch38
- Electric Starter Button39
- Ignition/Steering Lock39
- Immobilizer40
- Socket for Electrical Accessories40
- Opening the Filler Cap41
- Closing the Filler Cap42
- Fuel Cocks43
- Opening the Storage Compartment44
- Closing the Storage Compartment44
- Seat Lock45
- Tool Set45
- Grab Handles46
- Luggage Rack Plate46
- Passenger Footrests47
- Shift Lever47
- Side Stand48
- Center Stand49
7 Combination Instrument50
- Overview50
- Activation and Test50
- Matrix Display51
- Segment Display51
- Indicator Lamps52
- Message on the Matrix Display53
- Shift Warning Light54
- Service Display55
- Matrix Display Menu55
- Favorites55
- Trip 156
- Trip 256
- General Info57
- TPMS" (Optional)57
- Set Favorites58
- Settings58
- Warnings59
- Heat Grip" (Optional)59
- Mtc/Abs60
- Drive Mode60
- Menu Overview62
- Language63
- Distance64
- Temp64
- Volume65
- Pressure65
- Clock/Date66
- Fuel Cons66
- Drl67
- Shift Light67
- Quick Shift68
- Heat Grips68
8 Ergonomics69
- Handlebar Position69
- Adjusting the Handlebar Position69
- Adjusting the Wind Shield70
- Adjusting the Basic Setting of the Clutch Lever72
- Adjusting the Basic Position of the Hand Brake Lever72
- Rider Footrests73
- Adjusting the Footrests73
- Foot Brake Lever75
- Adjusting the Basic Position of the Foot Brake Lever75
- Checking the Basic Position of the Shift Lever77
- Adjusting the Basic Position of the Shift Lever77
9 Preparing for Use79
- Advice on First Use79
- Running in the Engine80
- Loading the Vehicle81
10 Riding Instructions83
- Checks and Maintenance Measures When Preparing for Use83
- Starting84
- Starting off85
- Shifting, Riding85
- Applying the Brakes89
- Stopping, Parking91
- Transport92
- Refueling93
11 Service Schedule95
- Additional Information95
- Required Work95
- Recommended Work98
12 Suspension Setting99
- Fork/Shock Absorber99
- Adjusting the Compression Damping of the Fork99
- Adjusting the Rebound Damping of the Fork100
- Adjusting the Spring Preload of the Fork101
- Compression Damping of the Shock Absorber102
- Adjusting the Low-Speed Compression Damping of the Shock Absorber102
- Adjusting the High-Speed Compression Damping of the Shock Absorber103
- Adjusting the Rebound Damping of the Shock Absorber104
- Adjusting the Spring Preload of the Shock Absorber105
13 Service Work on the Chassis107
- Raising the Vehicle with the Center Stand107
- Removing the Vehicle from the Center Stand107
- Removing the Seat108
- Mounting the Seat109
- Checking for Chain Dirt109
- Cleaning the Chain110
- Checking the Chain Tension111
- Adjusting the Chain Tension112
- Checking the Chain, Rear Sprocket and Engine Sprocket114
- Checking/Rectifying the Fluid Level of the Hydraulic Clutch117
- Checking the Steering Head Bearing Play118
- Removing the Bottom Triple Clamp Cover119
- Installing the Bottom Triple Clamp Cover119
- Removing the Front Side Cover120
- Installing the Front Side Cover121
- Removing the Mask Spoiler122
- Installing the Mask Spoiler125
- Removing the Front Fender127
- Installing the Front Fender128
- Removing the Tank Cover128
- Installing the Tank Cover130
- Removing the Wind Shield131
- Installing the Wind Shield132
14 Brake System133
- Abs/Antilock Brake System133
- Checking the Brake Discs135
- Checking the Brake Fluid Level of the Front Brake136
- Adding Front Brake Fluid136
- Checking the Front Brake Linings138
- Checking the Rear Brake Fluid Level139
- Adding Rear Brake Fluid140
- Checking the Rear Brake Linings142
15 Wheels, Tires143
- Removing the Front Wheel143
- Installing the Front Wheel145
- Removing the Rear Wheel147
- Installing the Rear Wheel149
- Checking the Rear Hub Rubber Dampers151
- Checking the Tire Condition153
- Checking the Tire Air Pressure154
- Checking Spoke Tension155
16 Electrical System157
- Daytime Running Light157
- Removing the Battery157
- Installing the Battery159
- Recharging the Battery160
- Changing the Main Fuse164
- Changing the Fuses in the Fuse Box166
- Removing the Headlight Mask with the Headlight168
- Refitting the Headlight Mask with the Headlight169
- Changing the Low Beam Bulb170
- Changing the High Beam Bulb171
- Changing the Turn Signal Bulb173
- Checking the Headlight Setting174
- Adjusting the Headlight Range175
- Activating/Deactivating the Ignition Key176
17 Cooling System181
- Checking the Coolant Level in the Compensating Tank181
- Correcting the Coolant Level in the Compensating Tank182
18 Engine Tuning184
- Drive Mode184
- Mtc/Motorcycle Traction Control184
19 Service Work on the Engine186
- Checking the Engine Oil Level186
- Changing the Engine Oil and Filter, Cleaning the Oil Screens187
- Adding Engine Oil191
20 Cleaning, Care194
- Cleaning Motorcycle194
- Checks and Maintenance Steps for Winter Operation196
21 Storage198
- Preparing for Use after Storage199
22 Troubleshooting200
23 Technical Data202
- Engine202
- Engine Tightening Torques203
- Capacities207
- Engine Oil207
- Coolant207
- Fuel207
- Chassis207
- Electrical System209
- Tires210
- Fork210
- Shock Absorber211
- Chassis Tightening Torques212
24 Substances216
25 Auxiliary Substances220
26 Standards222
- Index223

Brand	KTM
Model	1190 ADVENTURE R
Category	Motorcycle
Language	English

KTM 1190 ADVENTURE R User Manual

Table of Contents

Questions and Answers:

KTM 1190 ADVENTURE R Specifications

Related product manuals