Mahindra Genio DC BS-IV User Manual

Maintenance Manual MAN-00135
GENIO DC (BS-III & BS-IV) JULY 2011/Rev1
The repair methods given by the manufacturer in this document are based on the technical specifications, current at the time of release. The methods may be modified as a result of changes
introduced by the manufacturer in the production of the various component units and accessories from which the vehicles are manufactured. The reproduction, translation, transmission, in part of or
whole of the present document, are prohibited without the prior written consent of Mahindra & Mahindra Ltd. The use of this document by any person other than the trained personnel, at the
Authorized Service Centre of Mahindra & Mahindra Ltd., will amount to unauthorized use and shall be liable for penalty/prosecution © 2011 Mahindra & Mahindra Ltd.
12
705-MAT-0009 : 0.60 hrs.
COOLANT – REPLACE
Coolant Type: MAXIMILE ULTRA COOL (Pre-mixed)
Capacity: 8 Lit.
 Never remove the radiator cap when the engine is hot.
 Never mix MAXIMILE coolant with water. Maximile coolant is premixed/ ready
to use.
 Recommended to change the coolant at 60000 & then every 80000kms.
 Use Maximile ULTRA COOL
 Don’t use other coolants for top up. In case of emergency, coolant meeting JIS
K2234 specification should be used (30% concentration diluted with distilled
water) and coolant change period to be reduced as 30,000kms.
COOLANT – REPLACE
Refer illustrations shown.
1. Open the radiator cap
2. Remove the drain plug on the Engine block [B] and radiator bottom [A]
3. Drain the coolant and collect in drain tray.
4. Refit the drain plugs & fill new coolant in radiator
5. Check all the hoses & clips for leakage and correct fitment.
6. Start the engine and run at approx. 1200rpm for 2-3 min.
7. Check coolant level in radiator and add coolant as per requirement.
8. Fill coolant in the coolant recovery tank up to MAX level
9. Refit the radiator cap
10. Start the engine and run at approx. 1200rpm for 2-3 min.
11. Check coolant level in radiator and coolant recovery tank and add as required
B
Coolant Drain Plug on Block
A
Coolant Drain
cock on Radiator

Mahindra Genio DC BS-IV Specifications

General

Brand	Mahindra
Model	Genio DC BS-IV
Category	Automobile
Language	English