6 COOLANT
Mitsubishi Diesel Engine S16R & S16R2 OPERATION & MAINTENANCE MANUAL
112
Pub. No. K29001-00320 Revision: 1
LLC to Be Used
Use the genuine LLC.
• GLASSY Long Life Coolant
(ethylene glycol type)
• PG GLASSY long life coolant
(propylene glycol type)
• For GLASSY Long Life Coolant, 30%
diluted solution (18L [4.76 US gal],
200L [52.84 US gal]) is available.
When using the LLC other than genuine ones, use
the LLC which meets "Requirements for LLC" (→
Page 209) and "LLC Quality Standard" (→ Page
209). Do not mix and use LLC of different types
and/or manufacturers.
• If you use the LLC which does not meet
"Requirements for LLC" (→ Page
209) and "LLC Quality Standard" (→
Page 209), for the failure due to the
LLC, warranty will become invalid.
• The quality and performance of
commercially available LLC and their
component variations are the
responsibility of LLC suppliers.
• Before purchasing a commercial LLC,
be sure to discuss the suitability of LLC
with the LLC supplier.
• Be sure to use an all-season (non-
amine) type long life coolant that
prevent freezing of cooling water. Do
not use antifreeze alone instead of LLC.
For details, refer to
"Examples of
Abnormalities Caused by LLC (Amine
Type)" (→ Page 213).
Coolant (LLC) - Handling
Use the genuine LLC specified in this
Operation & Maintenance Manual.
* Otherwise, the devices could be damaged.
Keep away from fire, when working
with flammable substances such as
coolant (LLC).
* They may cause a fire.
Wipe off spilled flammable
substances such as coolant (LLC)
thoroughly with a waste cloth.
* They may cause a fire.
When discarding a waste cloth used
to wipe off combustible material, put
it into a lidded can and obey the
Waste Management and Public
Cleansing Act to handle it as a special
industrial waste.
* It may cause a fire.
* It could lead to environmental pollution.
* If you violate rules, you may be subject to
penalties.
Use care not to let oil mixed with
coolant.
* Otherwise, cooling fault could occur, which
could cause overheating.
When handling coolant (LLC), always
wear suitable personal protective
equipment such as rubber gloves and
protective eyeglasses.
* If LLC comes into contact with your eyes, it will
result in sight loss at the worst.
* If LLC comes into contact with your skin while
the engine is hot, you could get burned by heat.
To Next Page
Loading...
Need help?
General
