Operation Manual / TPS44-F.. - TPS61-F..
10 Mothballing the turbocharger / 10.1 Taking the engine out of opera-
tion for up to 12months
© Copyright 2020 . All rights reserved. HZTL2412_EN Rev.G March 2020
10 Mothballing the turbocharger
10.1 Taking the engine out of operation for up to
12months
Condition of engine lubricating oil
The turbocharger normally remains mounted on the engine. Mothballing
a turbocharger depends on the condition of the lubricating oil:
¡ If the total acid number (TAN) is lower than 2 mg KOH/g, no meas-
ures have to be taken.
¡ If the engine lubricating oil is replaced by preserving oil before taking
the engine out of operation and this is circulated by the pre-lubrica-
tion pump, no measures have to be taken. Any remaining old engine
oil will therefore be flushed away and the bearing sections largely
protected against corrosion.
Mothballing measures
WARNING
Handling operating materials and supplies
Swallowing or inhaling vapours of operating materials and supplies or
contact with them may be harmful to health.
u Do not breathe in these substances and avoid contact with the skin.
u Ensure proper ventilation.
u Observe the information in the material safety data sheet for the op-
erating materials and supplies.
u Wear personal protective equipment (PPE) according to the material
safety data sheet.
u Comply with local legislation.
Wear safety goggles.
Wear safety gloves to protect against chemical hazards.
Wear a respiratory mask to protect against gases.
Page 105 / 113
To Next Page
Loading...
Need help?
General
