Hyundai 160D-9 User Manual

9-2
2. ELECTRICAL SYSTEM
Trouble symptom
Lamps dimming even at maxi-
mum engine speed.
Lamps flicker during engine
operation.
Charge lamp does not light du
-ring normal engine operation.
Alternator makes abnormal
sounds.
Starting motor fails to run.
Starting motor pinion repeats
going in and out.
Excessively low starting motor
speed.
Starting motor comes to a
stop before engine starts up.
Heater signal does not beco-
me red.
* Heater functions only when
the coolant temperature is
below 0 ˚C
Engine oil pressure warning
lamp does not light when enig-
ne is stopped
(with starting switch left in"ON"
position).
 Caution lamp defective.
 Caution lamp switch defective.
 Replace
 Replace
 Faulty wiring.
 Glow plug damaged.
 Check and repair.
 Replace
 Faulty wiring.
 Insufficient battery voltage.
 Check and repair.
 Recharge battery.
 Insufficient battery voltage.
 Starting motor defective.
 Recharge battery.
 Replace
 Insufficient battery voltage.  Recharge battery.
 Faulty wiring.
 Insufficient battery voltage.
 Check and repair.
 Recharge battery.
 Alternator defective.  Replace
 Charge lamp defective.
 Faulty wiring.
 Replace.
 Check and repair.
 Improper belt tension.  Adjust belt tension.
 Faulty wiring.  Check for loose terminal and discon-
nected wire.
Probable cause Remedy

Hyundai 160D-9 Specifications

General

Brand	Hyundai
Model	160D-9
Category	Forklifts
Language	English