To Next Page

To Previous Page

13 SERVICE WORK ON THE CHASSIS 158

F00883-11

–

Mount and tighten screw

Guideline

Screw, mask spoiler M5x17 3.5 Nm

(2.58 lbf ft)

– Repeat these steps on the opposite side.

Finishing work

– Install the tank cover. ( p. 164)

– Install the front side cover. ( p. 152)

– Mount the seat. ( p. 140)

13.18 Removing the front fender

K00837-10

(Super Adventure R EU)

–

Open holder

and detach the brake lines and cable.

–

Remove screws

– Take the fender off to the front.

Info

Pay attention to the brake lines and the cable.

Default Chapter5
- Table of Contents5
1 Means of Representation10
- Symbols Used10
- Formats Used11
2 Safety Advice12
- Use Definition - Intended Use12
- Misuse12
- Degrees of Risk and Symbols13
- Tampering Warning13
- Safe Operation14
- Protective Clothing15
- Work Rules15
- Environment15
- Owner's Manual16
3 Important Notes17
- Warranty17
- Operating and Auxiliary Substances17
- Spare Parts, Accessories17
- Service18
- Figures18
- Customer Service18
4 View of Vehicle20
- View of Vehicle, Front Left (Example)20
- View of Vehicle, Rear Right (Example)22
5 Serial Numbers24
- Chassis Number24
- Type Label24
- Key Number25
- Engine Number26
- Fork Part Number26
- Shock Absorber Article Number27
- Steering Damper Article Number27
6 Controls28
- Clutch Lever28
- Hand Brake Lever28
- Throttle Grip29
- Combination Switch, Left Side29
- Light Switch30
- Cruise Control System Tip Switch30
- Menu Switch32
- Turn Signal Switch33
- Horn Button34
- Combination Switch, Right34
- Hazard Warning Flasher Switch35
- Emergency off Switch/Electric Starter Button35
- Race-On Button36
- Steering Lock (Antenna)36
- Immobilizer37
- Race-On Key37
- Socket for Electrical Accessories38
- USB Socket39
- Opening the Filler Cap39
- Closing the Filler Cap41
- Fuel Cocks41
- Opening Storage Compartment42
- Closing Storage Compartment42
- Seat Lock43
- Grab Handles43
- Luggage Rack Plate44
- Passenger Footrest44
- Shift Lever45
- Foot Brake Lever46
- Side Stand46
- Center Stand47
7 Combination Instrument48
- Activation and Test49
- Day-Night Mode49
- Warning Notes50
- Warning of Icy Roads51
- Indicator Lamps52
- Display56
- Speed58
- Shift Warning Light59
- Cruise Control Indicator60
- Speed60
- Ride Mode Display61
- Heated Grip (Optional)61
- Seat Heating (Optional)62
- Coolant Temperature Indicator62
- Fuel Level Display63
- Ambient Temperature Indicator63
- Time64
- Favourites Display64
- Quick Selector 1 Display65
- Quick Selector 2 Display65
- Menu66
- KTM MY RIDE (Optional)66
- Info67
- Motorcycle67
- Settings68
- Preferences68
- Pairing (Optional)69
- Audio (Optional)70
- Telephony (Optional)72
- Trip 173
- Trip 273
- 7.22.11 General Info74
- 7.22.12 Tpms74
- 7.22.13 Warnings76
- Heated Grips (Optional)76
- Heated Seat (Optional)77
- 7.22.16 Ride Mode77
- 7.22.17 Mtc78
- MTC+MSR (Optional)79
- 7.22.19 Abs80
- HHC (Optional)81
- 7.22.21 Favourites81
- Quick Selector 182
- Quick Selector 282
- 7.22.24 Distance83
- 7.22.25 Temp83
- 7.22.26 Pressure84
- 7.22.27 Consumption84
- 7.22.28 Language85
  - 7.22.29 Shift Light86
  - 7.22.30 Setting the Time and Date86
  - 7.22.31 Drl88
  - Quick Shift + (Optional)89
  - Heated Grips (Optional)90
  - Heated Seat Rid (Optional)90
  - Heated Seat Pas (Optional)91
  - 7.22.36 Cornering Light Test91
  - 7.22.37 Service92
  - 7.22.38 Extra Functions93
8 Ergonomics94
- Handlebar Position94
- Adjusting the Handlebar Position94
- Adjusting the Windshield96
- Adjusting Basic Position of Clutch Lever97
- Adjusting the Basic Position of the Hand Brake Lever97
- Rider Footrests98
- Adjusting the Footrests98
- Checking the Basic Position of the Shift Lever101
- Adjusting the Basic Position of the Shift Lever101
- Setting the Shift Lever Stub103
- Adjusting the Basic Position of the Foot Brake Lever104
- Adjusting the Tilt of the Combination Instrument105
9 Preparing for Use107
- Advice on First Use107
- Running in the Engine108
- Loading the Vehicle109
10 Riding Instructions111
- Riding Instructions111
- Checks and Maintenance Measures When Preparing for Use111
- Starting112
- Starting off114
- Quickshifter+ (Optional)114
- Starting off with HHC115
- Shifting, Riding115
- MSR (Optional)120
- Applying the Brakes120
- Stopping, Parking122
- Transport124
- Refueling125
11 Service Schedule128
- Additional Information128
- Required Work128
- Recommended Work130
12 Suspension Setting132
- Suspension Setting132
- Fork/Shock Absorber132
- Adjusting the Compression Damping of the Fork132
- Adjusting the Rebound Damping of the Fork133
- Adjusting the Spring Pretension of the Fork134
- Compression Damping of the Shock Absorber135
- Adjusting the Low-Speed Compression Damping of the Shock Absorber135
- Adjusting the High-Speed Compression Damping of the Shock Absorber136
- Adjusting the Rebound Damping of the Shock Absorber137
- Adjusting the Spring Pretension of the Shock Absorber138
13 Service Work on the Chassis140
- Raising the Vehicle with the Center Stand140
- Removing the Vehicle from the Center Stand140
- Removing the Seat141
- Mounting the Seat142
- Checking for Chain Dirt142
- Cleaning the Chain143
- Checking the Chain Tension144
- Adjusting the Chain Tension145
- Checking the Chain, Rear Sprocket, and Engine Sprocket147
- Checking/Correcting the Fluid Level of the Hydraulic Clutch150
- Checking the Steering Head Bearing Play151
- Removing the Bottom Triple Clamp Cover152
- Installing the Bottom Triple Clamp Cover153
- Removing the Front Side Cover154
- Installing the Front Side Cover154
- Removing the Mask Spoiler155
- Installing the Mask Spoiler158
- Removing the Front Fender160
- Installing the Front Fender161
- Cleaning the Dust Boots of the Fork Legs162
- Removing the Tank Cover164
- Installing the Tank Cover166
- Removing the Wind Shield168
- Installing the Wind Shield168
- Removing the Engine Guard169
- Installing the Engine Guard169
- Removing the Crash Bar170
- Installing the Crash Bar171
14 Brake System173
- Antilock Brake System (ABS)173
- Checking the Brake Discs175
- Checking the Brake Fluid Level of the Front Brake176
- Adding Front Brake Fluid177
- Checking the Front Brake Linings178
- Checking the Rear Brake Fluid Level179
- Adding Rear Brake Fluid180
- Checking the Rear Brake Linings182
15 Wheels, Tires184
- Removing the Front Wheel184
- Installing the Front Wheel186
- Removing the Rear Wheel189
- Installing the Rear Wheel191
- Checking the Rear Hub Rubber Dampers194
- Checking the Tire Condition195
- Checking the Tire Air Pressure197
- Checking Spoke Tension198
- Tubeless Tire System199
16 Electrical System200
- Daytime Running Light (DRL)200
- Cornering Headlight201
- Removing the Battery201
- Installing the Battery203
- Recharging the Battery205
- Changing the Race-On Key Battery209
- Changing the Main Fuse210
- Changing the Fuses in the Fuse Box212
- Checking the Headlight Setting215
- Adjusting the Headlight Range215
- Diagnostics Connector217
17 Cooling System218
- Checking the Coolant Level in the Compensating Tank218
- Correcting the Coolant Level in the Compensating Tank219
18 Tuning the Engine222
- Ride Mode222
- Motorcycle Traction Control (MTC)222
19 Service Work on the Engine224
- Checking the Engine Oil Level224
- Changing the Engine Oil and Oil Filter, Cleaning the Oil Screens225
- Adding Engine Oil229
20 Cleaning, Care232
- Cleaning Motorcycle232
- Checks and Maintenance Steps for Winter Operation234
21 Storage236
- Preparing for Use after Storage237
22 Troubleshooting238
23 Technical Data240
- Engine240
- Engine Tightening Torques241
- Capacities245
- Engine Oil245
- Coolant245
- Fuel245
- Chassis245
- Electrical System247
- Tires248
- Fork248
- Shock Absorber249
- Chassis Tightening Torques251
24 Declarations of Conformity255
- EU Declaration of Conformity255
25 Open Source256
- Information on Open Source Software256
26 Substances257
27 Auxiliary Substances260
28 Standards262
29 Index of Special Terms263
30 List of Abbreviations264
31 List of Symbols265
- Red Symbols265
- Yellow and Orange Symbols265
- Green and Blue Symbols266
- Index267

Brand	KTM
Model	1290 SUPER ADVENTURE R 2017
Category	Motorcycle
Language	English

KTM 1290 SUPER ADVENTURE R 2017 User Manual

Table of Contents

Other manuals for KTM 1290 SUPER ADVENTURE R 2017

Questions and Answers:

KTM 1290 SUPER ADVENTURE R 2017 Specifications

Related product manuals