Maintenance Section 4
38
Part Number 000007345 2/14
Cleaning / Sanitizing Procedure
CLEANING PROCEDURE
Ice machine cleaner is used to remove lime scale and
mineral deposits. Ice machine sanitizer disinfects and
removes algae and slime.
NOTE: Although not required and dependent on your
installation, removing the ice machine top cover may
allow easier access.
Step 1 Open the front door to access the evaporator
compartment. Ice must not be on the evaporator during
the clean/sanitize cycle. Follow one of the methods
below:
• Press the power switch at the end of a harvest cycle
after ice falls from the evaporator(s).
• Press the power switch and allow the ice to melt.
Step 2 Remove all ice from the bin/dispenser.
Step 3 Press the clean button. Water will flow through
the water dump valve and down the drain. Wait until the
water trough refills and the display indicates add
chemical (approximately 1 minute), then add the proper
amount of ice machine cleaner.
Step 4 Wait until the clean cycle is complete
(approximately *24 minutes). Then disconnect power to
the ice machine (and dispenser when used).
Step 5 Remove parts for cleaning.
Please refer to the proper parts removal for your ice
machine. Continue with step 6 when the parts have
been removed.
Single Evaporator Ice Machines - Page 40
Use only Manitowoc approved Ice Machine Cleaner
and Sanitizer for this application (Manitowoc
Cleaner part number 94-0546-3 and Manitowoc
Sanitizer part number 94-0565-3). It is a violation of
Federal law to use these solutions in a manner
inconsistent with their labeling. Read and
understand all labels printed on bottles before use.
Do not mix Cleaner and Sanitizer solutions together.
It is a violation of Federal law to use these solutions
in a manner inconsistent with their labeling.
Wear rubber gloves and safety goggles (and/or face
shield) when handling Ice Machine Cleaner or
Sanitizer.
Never use anything to force ice from the evaporator.
Damage may result.
Model Amount of Cleaner
I0300/I0320/I0520 3 ounces (90 ml)
I0450/I0500/I0600/I0850
I0900/I1000/I1100/I1200
5 ounces (150 ml)
I1400/I1800 9 ounces (265 ml)
Disconnect the electric power to the ice machine at
the electric service switch box.
To Next Page
Loading...
Need help?
General