Home
Mitsubishi
Controller
MELSEC
Mitsubishi MELSEC User Manual
4
of 1
of 1 rating
200 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
10
- 18
10.3 Wiring
10.3.1 The precautions o
n the wiring
10
LOADING AND INSTALLATION
10.3 Wiring
10.3.1 The precautions on the wiring
DANGER
Be sure to shu
t off all phases of the e
xternal supply p
ower used by th
e
system befo
re wiring.
Not completely turning off
all power
could result in electric shock or dam-
age to the product.
When energizing or ope
rating the module af
ter inst
allation or wiring, be
sure to close the att
ached terminal cover
.
Not doing so may result in electric shock.
85
87
Table of Contents
Default Chapter
5
Specification •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••6
5
Cables •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••9
6
Table of Contents
11
Contents
14
Introduction
14
Revisions
14
Safety Precautions
14
About Manuals
18
Others •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••9
18
How this Manual Is Organized
20
How to Use this Manual
22
Chapter6 Base Unit
23
Generic Terms and Abbreviations
23
Precautions for Use
24
Chapter1 Overview
25
Features
27
Chapter2 System Configuration
31
System Configuration
31
Precautions for System Configuration
33
Configuration of Peripheral Devices
34
Confirming Serial No. and Function Version
35
Chapter3 General Specifications
37
Chapter4 Cpu Module
38
Performance Specifications
38
Sequence Program
38
Part Names
40
Initial Processing
41
Switch Operation after Writing a Program
42
Reset Operation
43
Chapter5 Power Supply Module
45
Specifications
45
Precaution When Connecting the Uninterruptive Power Supply
47
Names of Parts and Settings
48
Chapter7 Battery
52
Battery (Q6BAT)
52
Battery Specifications
52
Installation of Battery
53
Chapter8 Cpu Module Start-Up Procedures
54
Procedure before Operating in SAFETY MODE
54
Chapter9 Emc And Low Voltage Directives
57
Requirements for Conformance to EMC Directive
57
Standards Relevant to the EMC Directive
57
Installation Instructions for EMC Directive
59
Cables
60
Power Supply Module
62
Others
63
Requirement to Conform to the Low Voltage Directive
65
Standard Applied for MELSEC-QS Series PLC
65
MELSEC-QS Series PLC Selection
65
Power Supply
66
Control Panel
66
Grounding
68
External Wiring
68
Chapter10 Loading And Installation
69
Calculating Heat Generation of PLC
71
Module Installation
73
Precaution on Installation
73
Instructions for Mounting the Base Unit
80
Installation and Removal of Module
83
Wiring
86
The Precautions on the Wiring
86
Connecting to the Power Supply Module
90
Chapter11 Maintenance And Inspection
91
Daily Inspection
93
Periodic Inspection
94
Battery Life and Replacement Procedure
95
Battery Lives of CPU Modules
96
Replacement Procedure of the CPU Module Battery
98
When PLC Has Been Stored Without a Battery
99
When Battery Has Gone Flat During Storage of a PLC
100
Chapter12 Troubleshooting
101
Troubleshooting Basics
101
Troubleshooting Flowchart
102
Troubleshooting Category Flow
102
Flowchart for When the ERR Terminal (Negative Logic) Is off (Opened)
103
Flowchart for When the "POWER" LED Turns off
105
When the "ALIVE" LED Does Not Turn on or Turns off
107
Flowchart for When the "RUN" LED Turns off
109
When the "RUN" LED Flashes
110
Flowchart for When the "ERR." LED Turns on or Flashes
111
When the "USER" LED Turns on
114
When the "BAT." LED Turns on
115
Flowchart for When a Program Cannot be Read
116
Flowchart for When a Program Cannot be Written
117
Flowchart for When the CPU Cannot Communicate with the GX Developer
118
Error Code List
120
Error Codes
121
Reading an Error Code
121
Error Code List (1000 to 1999)
122
Error Code List (2000 to 2999)
128
Error Code List (3000 to 3999)
134
Error Code List (4000 to 4999)
142
Error Code List (5000 to 5999)
146
Error Code List (8000 to 9000)
148
Canceling Errors
156
Error Codes Returned to Request Source During Communication with CPU Module
158
Special Relay List
167
Special Register List
171
Appendix 1 External Dimensions •••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••••• App- 1
187
Appendices
187
Appendix 1.1 CPU Module
187
Appendix 1.2 Power Supply Module
188
Appendix 1.3 Main Base Unit
189
Appendix 2 Safety CPU Module Upgrade
190
Appendix 3 Precautions for Battery Transportation
191
Appendix 4 Handling of Batteries and Devices with Built-In Batteries in EU Member States
192
Appendix 4.1 Disposal Precautions
192
Appendix 4.2 Exportation Precautions
193
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Mitsubishi MELSEC and is the answer not in the manual?
Ask a question
Mitsubishi MELSEC Specifications
General
Brand
Mitsubishi
Model
MELSEC
Category
Controller
Language
English
Related product manuals
Mitsubishi MELSEC-Q/L
850 pages
Mitsubishi MELSEC QCPU
285 pages
Mitsubishi MELSEC A1SY10
149 pages
Mitsubishi MELSEC A1SX40
149 pages
Mitsubishi MELSEC A1SY80
149 pages
Mitsubishi MELSEC A1SCPU
149 pages
Mitsubishi MELSEC A1SD70
149 pages
Mitsubishi MELSEC A1S62P
149 pages
Mitsubishi MELSEC A1S61P
149 pages
Mitsubishi MELSEC A1SG60
149 pages
Mitsubishi MELSEC A1SX81
149 pages
Mitsubishi MELSEC F2-60MR
28 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
