D
Group 177 Preventive Maintenance
Preventive Maintenance
Check Oil Level in Automatic Transmission
Date: Model: Reg. No.:
Time: Vehicle Identification Number: Engine:
Dealer Code: Transmission
Name: Rear Axle:
X = Corrected without comment
√ Correction not needed
N = Not relevant or applicable
Lubrication, Oil and Fluid Level Check
1 Chassis Lubrication
2 Cab Lubrication
3 Change Engine Oil and Filter
4 Check Oil Level in Manual Transmission
5 Check Oil Level in Automatic Transmission
6 Check Oil Level in PTO, Power Take-Off
7 Check Oil Level in Retarder
8 Check Oil Level in Transfer Case
9 Check Oil Level in Front Drive Axle
10 Check Oil Level in Rear Drive Axle
11 Check Oil Level in Hydraulic Lift Axle
12 Check Oil Level in Power Steering
13 Check Oil Level in Hubs for Oil Lubricated Wheel
Bearings
14 Check Oil Level in Cab Tilt Pump
15 Check Fluid Level in Clutch Fluid Reservoir
16 Check Coolant Freeze Protection and Coolant Level
17 Check Fluid Levels in Windshield Wiper and
Headlamp Wiper Reservoirs
18 Check Air Dryer
Checks in Cab
19 Check Warning and Control Lamps
20 Check Fault Codes in the Vehicle Electronic
Control Unit
21 Check Fault Codes in the Engine Electronic
Control Unit
22 Check Fault Codes in the ABS, Anti-Lock Brakes
23 Check Fault Codes in Transmission
24 Function Check of Parking Heater
25 Check Engine Control in Cab
26 Check Retarder Control
27 Start Engine and Check of Starter Element and
Preheater
28 Check Pressure Regulator’s Disconnection and
Connection Pressure
29 Check Air Compressor’s Function and Condition
30 Check Sealing on Main Brake Circuit (Service)
31 Check Parking Brake and Blocking Valve
32 Check Gearshift and Clutch Pedal
33 Check Bogie Lift
34 Check Brake Pedal and Foot Brake Valve
35 Check Hinges, Doorstops, Locks and Sealing
Strips
25
To Next Page
Loading...
Need help?
General
