Generac Power Systems XT-EFI Series User Manual

Table of Contents
Diagnostic Repair Manual vi
Test 17 – Check START-RUN-STOP Switch
(410/426cc Engine) .................................................28
Test 18 – Test OFF-ON Switch ...............................28
Test 19 – Check Starter Motor ................................28
Test 20 – Check Ignition Spark ...............................29
Test 21 – Check Spark Plugs .................................30
Test 22 – Check Carburetion ..................................30
Test 23 – Choke Test .............................................31
Test 24 – Check Valve Adjustment .........................31
Test 25 – Check Engine / Cylinder Leak
Down Test / Compression Test ...............................32
Test 26 – Check Ignition Coil ..................................33
Test 27 – Check Flywheel .......................................33
Test 28 – Remove Shutdown Wire .........................34
Test 29 – Check / Adjust Governor
(208/389/420cc Non-EFI Engine) ...........................34
Test 30 – Check / Adjust Governor
(220/410/530cc Non-EFI Engine) ...........................35
Test 31 – Check Oil Pressure Switch .....................35
Test 32 – Check Oil Level Switch ...........................36
Test 33 – Test Recoil Function ...............................36
Test 34 – Test Engine Function ..............................36
Test 35 – Test Battery Charger (Non-EFI Units) .....36
Test 36 – Test Battery Charging Circuit
(EFI Electric Start Models) ......................................37
Test 37 – Test Idle Control .....................................37
Section 6 Major Disassembly ....................................39
Introduction .............................................................39
Section 7 Electrical Data ............................................49
Introduction .............................................................49
Wiring Diagram and Electrical Schematic,
RS5500 Drawing No. 0K6393-A ............................ 50
Wiring Diagram and Electrical Schematic,
RS7000E Drawing No. 0K6394-C .......................... 54
Wiring Diagram and Electrical Schematic,
XC6500 Drawing No. 10000010344-A 58
Wiring Diagram and Electrical Schematic,
XC6500E/XC8000E Drawing No. 10000010343-A 62
Wiring Diagram and Electrical Schematic,
XP4000 Drawing No. 0H8536-D ............................ 66
Wiring Diagram and Electrical Schematic,
XP5600E & XP6400E Drawing No. 0K2042-A ...... 70
Wiring Diagram and Electrical Schematic,
XP6500E Drawing No. 0H6809-D .......................... 72
Wiring Diagram and Electrical Schematic,
XP6500E Drawing No. 0H6809-D .......................... 75
Wiring Diagram and Electrical Schematic,
XP8000E Drawing No. 0H7588-C .......................... 76
Wiring Diagram and Electrical Schematic,
XP10000E Drawing No. 0H7214-D ....................... 80
Wiring Diagram and Electrical Schematic,
XG4000 Drawing No. 0H3339-E ............................ 84
Wiring Diagram and Electrical Schematic,
XG4000 Drawing No. 0H5278-A ............................ 86
Wiring Diagram and Electrical Schematic,
XG5600E/XG6400E Drawing No. 0J8223-B ......... 88
Wiring Diagram and Electrical Schematic,
XG6500 Drawing No. 0H2780-F ............................ 90
Wiring Diagram and Electrical Schematic,
XG7000E Drawing No. 0H3525-C ......................... 92
Wiring Diagram and Electrical Schematic,
XG8000E Drawing No. 0H5145-A ......................... 94
Wiring Diagram and Electrical Schematic,
XG10000E Drawing No. 0H3931-B ....................... 96
Wiring Diagram and Electrical Schematic,
XT8000E Drawing No. 0K2800-C ........................ 100
Wiring Diagram and Electrical Schematic,
HL6500E Drawing No. 0L2474-A ........................ 101
Wiring Diagram and Electrical Schematic,
HL6500E Drawing No. 0K9434-B ........................ 103
Wiring Diagram and Electrical Schematic,
HL6500E Drawing No. 0K9433-B ........................ 104
Wiring Diagram, XT8000EFI Drawing No.
10000023894-A ................................................... 106
Electrical Formulas ...............................................107

Generac Power Systems XT-EFI Series Specifications

General

Brand	Generac Power Systems
Model	XT-EFI Series
Category	Portable Generator
Language	English