SAFETY MESSAGES
1-2 www.honeywellgenerators.com Honeywell Portable Electrical Generator Service Manual
Electric Shock Hazards
Fire and Burn Hazards
Medical and Life Support Uses
Generator Damage Hazards
Generators produce powerful voltage that can cause
death or great physical harm.
• NEVER touch bare wires or receptacles.
• NEVER use generator with electrical cords that are
worn, frayed, bare, or otherwise damaged.
• NEVER operate generator in rain or snow, or when the
generator is set on wet surface.
• Exposed terminals, even on disconnected batteries,
can cause electric shock.
• NEVER touch both battery terminals with bare hands
at the same time.
• Remove rings, watches or any other object containing
metal when working with battery. If metal comes into
contact with battery terminals, electric shock and seri-
ous burns can result.
• Only use insulated/non-conducting tools when working
with or near battery.
• NEVER lay tools or other metal objects on top of bat-
tery.
Fuel and its vapors are extremely flammable and
explosive under certain conditions.
• Refuel generator only outdoors, in a well-ventilated
area.
• NEVER enclose the generator in any structure.
• Keep generator at least 6 feet (2 meters) away from
buildings, other equipment, and combustible materials
during operation.
• NEVER fill fuel tank while the engine is running. Turn
generator OFF and allow to cool before filling with fuel.
• NEVER smoke or allow flames or sparks near the gen-
erator or where gasoline is stored.
• NEVER overfill the fuel tank (there should be no fuel in
the filler neck). After refueling, make sure the tank cap
is closed properly and securely.
• Be careful not to spill fuel when refueling. Spilled fuel
or fuel vapor may ignite. If any fuel is spilled, be sure
the area is dry before starting the engine.
• Avoid repeated or prolonged contact with skin or
breathing of vapor.
The muffler becomes very hot during operation and
remains hot for a while after stopping the engine.
• NEVER touch hot surfaces and avoid hot gases.
• Let engine cool before storing the generator indoors.
Battery gases are explosive.
• NEVER allow open flames, lit cigarettes, sparks, or
spark-producing equipment near the battery.
Battery electrolyte fluid is comprised of sulfuric acid,
which can be very dangerous and cause severe
burns.
• NEVER allow battery fluid to contact eyes, skin, or
clothing. If contact or spillage occurs, immediately flush
the area with water.
• In case of emergency, call 911 immediately.
• NEVER use this product to power life support devices
or life support appliances.
• NEVER use this product to power medical devices or
medical appliances.
• Inform your electricity provider immediately if you or
anyone in your household depends on electrical equip-
ment to live.
• Inform your electrical provider immediately if a loss of
power would cause you or anyone in your household to
experience a medical emergency.
NOTICE
Improper treatment or misuse of generator can cause per-
manent damage.
• NEVER modify generator in any way.
• NEVER tamper with governed speed. Generator sup-
plies correct rated frequency and voltage when run-
ning at governed speed.
• Damage to generator caused by misuse or modifica-
tion is not covered under warranty.
To Next Page
Loading...
Need help?
General
