Kubota BX24D - Page 19

To Next Page

To Previous Page

9SAFE OPERATION

Main Page

Table of Contents5
Safe Operation11
Backhoe18
Tractor27
Servicing27
Specifications of the Tractor28
Specification Table28
Traveling Speeds29
Specifications of the Loader30
Loader Specifications30
Bucket Specifications30
Dimensional Specifications31
Loader32
Operational Specifications32
Loader Terminology34
Specifications of the Backhoe35
Backhoe Specifications35
Dimensions35
Specifications36
Lift Capacity (Per SAE J31)38
Backhoe Terminology39
Implement Limitations40
Instrument Panel and Controls42
Pre-Operation Check of the Tractor44
Daily Check44
Pre-Operation Check of the Loader45
Lubrication45
Transmission Fluid45
Rear Ballast45
Liquid Ballast in Rear Tires45
Tire Inflation45
Test Operation45
Removing Air from Hydraulic System46
Pre-Operation Check of the Backhoe47
Pre-Operation Checks47
Operator's Seat47
Ballast47
Tire Inflation47
Operating the Engine48
Starting the Engine48
Cold Weather Starting50
Block Heater (Option)50
Stopping the Engine50
Easy Checker(TM)50
Warming up51
Warm-Up and Transmission Oil in the Low Temperature Range51
Jump Starting51
Operating the Tractor52
Operating New Tractor52
Do Not Operate the Tractor at Full Speed for the First 50 Hours52
Changing Lubricating Oil for New Tractors52
Operating Foldable Rops52
To Fold the ROPS52
To Raise the ROPS to Upright Position53
Adjustment of Foldable ROPS54
Starting55
Operator's Seat55
Seat Belt55
Head Light Switch55
Hazard Light Switch55
Turn Signal Light Switch56
Brake Pedal56
Head Light Switch56
Hazard Light Switch56
Range Gear Shift Lever (Hi-Lo)57
Front Wheel Drive Lever57
Hand Throttle Lever58
Parking Brake Pedal58
Speed Control Pedal58
Speed Set Device59
Stopping60
Check During Driving60
Immediately Stop the Engine if60
Easy Checker(TM)60
Fuel Gauge60
Coolant Temperature Gauge60
Coolant Temperature Gauge61
(1) Hourmeter / Tachometer61
Fuel Gauge61
Parking62
Accessory62
(1) 12V Electric Outlet62
Operator's Manual Holder62
Operating Techniques63
Differential Lock63
Operating the Tractor on a Road63
Operating on a Slopes and Rough Terrain64
Directions for Use of Power Steering64
Reversing the Seat64
Pto66
Pto Operation66
PTO Select Lever66
PTO Clutch Lever67
PTO Shaft Cover and Shaft Cap67
Stationary PTO67
PTO Drive Shaft68
Three-Point Hitch & Drawbar69
3-Point Hitch70
Attaching and Detaching Implements70
Lifting Rod (Right)70
Top Link70
Check Chains70
Hitch70
Removing the 3-Point Hitch71
Installing the 3-Point Hitch71
Hydraulic Unit72
3-Point Hitch Control System72
Hydraulic Control72
3-Point Hitch Lowering Speed72
Auxiliary Hydraulics73
Hydraulic Outlet73
Installing Mower73
Mower Lift Linkage System74
Cutting Height Control Dial74
Hydraulic Control Unit Use Reference Chart75
Tires, Wheels and Ballast76
Tires76
Inflation Pressure76
Wheel Tread76
Front Wheels76
Rear Wheels77
Ballast78
Front Ballast78
Rear Ballast78
Operating the Loader79
Filling the Bucket79
Lifting the Load79
Carrying the Load80
Dumping the Bucket80
Lowering the Bucket80
Operating with Float Control80
Loading from a Bank81
Peeling and Scraping81
Loading Low Trucks or Spreaders from a Pile82
Backfilling82
Handling Large Heavy Objects83
Valve Lock83
Operating the Backhoe84
Operating Speed84
Backhoe Controls84
Boom & Swing Lever84
Dipperstick & Bucket Lever85
Stabilizer Control Levers85
Placing the Stabilizers85
General Backhoe Operation86
Dipperstick Digging86
Spoil Pile Location86
Straight Wall or Cemetery Digging86
Stabilizer Pads (Standard)87
Stabilizer Pads (Option)87
Transporting88
Driving to the Job-Site88
Trailer Transporting88
Maintenance of the Tractor89
Service Intervals89
Lubricants90
Periodic Service of the Tractor92
How to Open the Hood92
Hood92
Engine Cover92
Daily Check93
Walk Around Inspection93
Checking and Refueling94
Checking Engine Oil Level94
Checking Transmission Fluid Level95
Checking Coolant Level95
Cleaning Panel and Radiator Screen96
Checking Brake Pedal96
Checking Gauges, Meters and Easy Checker(TM)96
Checking Head Light, Hazard Light Etc96
Checking and Cleaning of Electrical Wiring and Battery Cables96
Checking Seat Belt and ROPS97
Every 50 Hours97
Checking Engine Start System97
Lubricating Grease Fittings98
Checking Wheel Bolt Torque98
Every 100 Hours99
Battery99
Changing Engine Oil100
Cleaning Air Cleaner Element101
Checking Fuel Lines and Fuel Filter101
Adjusting Fan Belt Tension102
Adjusting HST Neutral Spring (for Speed Control Pedal)102
Adjusting Brake Pedal103
Every 200 Hours103
Replacing Engine Oil Filter103
Checking Radiator Hose and Clamp104
Adjusting Toe-In104
Checking Intake Air Line105
Checking Power Steering Line105
Every 300 Hours106
Changing Transmission Fluid106
Cleaning Transmission Strainer106
Replacing Transmission Oil Filter107
Changing Front Axle Case Oil107
Every 400 Hours108
Adjusting Front Axle Pivot108
Every 500 Hours108
Replacing Fuel Filter108
Every 800 Hours108
Adjusting Engine Valve Clearance108
Every 1500 Hours108
Checking Fuel Injection Nozzle Injection Pressure108
Every 3000 Hours108
Checking Injection Pump108
Anti-Freeze109
Replacing Radiator Hose (Water Pipes)109
Replacing Power Steering Hose109
Replacing Fuel Lines109
Replacing Intake Air Line109
Service as Required110
Bleeding Fuel System110
Replacing Fuse110
Replacing Light Bulb111
Maintenance of the Loader112
Lubrication112
Re-Tightening of Hardware112
Tightening Bolts and Nuts112
Daily Checks113
Maintenance of the Backhoe114
Daily Checks114
Lubrication115
Bucket Service115
Changing the Backhoe Bucket115
Changing the Bucket Teeth115
General Torque Specification116
Storage of the Tractor117
Tractor Storage117
Removing the Tractor from Storage117
Removing the Loader118
Storage of the Loader119
Reinstalling the Loader120
Removing the Backhoe121
Removal of the Backhoe121
Storage of the Backhoe123
Reinstalling the Backhoe124
Troubleshooting126
Engine Troubleshooting126
Options127

Kubota BX24D - Page 19

Table of Contents

Related product manuals