Onan CCK Series User Manual

38
PERIODIC SERVICE
Follow a definite schedule of inspection and servicing to assure the best
. performance and long life of the plant. Service periods outlined below
are for average service and normal operating conditions. Under un-
usual service or abnormal operating conditions, service the plant more
frequently. Keep a record of the hours the plant is operated each day to
assure servicing at the proper time.
DAILY SERVICE
If the plant is operated more than 8 hours daily, perform
the following .services each 8 hours of operation.
FUEL. - Check the fuel supply often enough to avoid running 'out of fuel.
NEVER
FILL THE FUEL TANK WHILE THE PLANT IS RUN-
NING. Use clean, fresh,regular automotive type gasoline of at least
68 octane rating. Use of a highly leaded premium grade of gasoline is
not recommended.
CRANKCASE OIL LEVEL. - R-emove the oil fill cap and check the crank-
,. , case oil level. Add oil as necessary to
keep the oil level at the full mark on the gauge. Recommended grades
ofoil.ar~ "given underPREPAR~TION. Avoid overfilliilg whIch will
allow the connecting rod to strike the oil and cause oil foamlngwhich
interferes with efficient lubrication.
. " ~ . ~
The oil fill cap gasket must always be in· good condition and the cap must
always be securely tightened in place. Air leakage into the crankcase
at thigpoint 'Will cause oil carry-over at the breather , excessive oil con-
sumptionand possible oil leakage around the seals.
AID CLEANER. - Turn the thumb screw, located at the bottom of the
air cleaner cup, out as far as it will go and remOve
the cup. Add oil as necessary to raise the level to the indicated level
with oUof the same SAE number as used in the engine crankcase, except
as instructed under ABNORMAL OPERATING CONDITIONS.
FIG. 27 - AIR CLEANER SERVICE

Onan CCK Series Specifications

General

Brand	Onan
Model	CCK Series
Category	Portable Generator
Language	English