11
9926816 R07 - 2014-2016 RZR XP 1000 / XP4 1000 Service Manual
© Copyright Polaris Industries Inc.
11.23
BATTERY
BATTERY SPECIFICATIONS
Type
Polaris / Johnson Controls 575
Sealed - Maintenance Free
Voltage
12 Vdc
Nominal Capacity
@ 10 HR Rate
30 AH
CCA
575
Nominal Open
Circuit Voltage
12.8 Vdc or more.
Recommended
Charging Rate
1.8A @ 5-10 HR or 6.0A @ 1
HR
NOTE
Never attempt to open the battery. If the seal is broken,
the battery will be ruined and will fail within a few
weeks.
GENERAL BATTERY INFORMATION
WARNING
CALIFORNIA PROPOSITION 65 WARNING:Batteries,
battery posts, terminals and related accessories contain
lead and lead compounds, and other chemicals known
to the State of California to cause cancer and birth
defects or other reproductive harm. WASH HANDS
AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains acid!
Serious burns can result from contact with the skin,
eyes, or clothing.
ANTIDOTE:
External: Flush with water.
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil. Call
a physician immediately.
Eyes: Flush with water for 15 minutes and get prompt
medical attention.
Batteries produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
batteries.
Keep out of reach of children.
1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to
be recharged (see Chapter 11 – Charging Procedure
, page 11.25).
To service a Maintenance Free battery:
3. Remove battery from the vehicle (see Battery
Removal, page 2.40).
4. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to OCV table (see OCV - Open
Circuit Voltage Test, page 11.24).
5. Charge the battery as recommended (see –
Charging Procedure , page 11.25).
ELECTRICAL
To Next Page
Loading...
Need help?
General
