2
9926816 R07 - 2014-2016 RZR XP 1000 / XP4 1000 Service Manual
© Copyright Polaris Industries Inc.
2.19
FUEL SYSTEM AND AIR INTAKE
FUEL SYSTEM WARNING
WARNING
Gasoline is extremely flammable and explosive under
certain conditions.
Always stop the engine and refuel outdoors or in a well
ventilated area.
Do not smoke or allow open flames or sparks in or near
the area where refueling is performed or where
gasoline is stored.
Do not overfill the tank. Do not fill the tank neck.
If you get gasoline in your eyes or if you swallow
gasoline, seek medical attention immediately.
If you spill gasoline on your skin or clothing,
immediately wash it off with soap and water and
change clothing.
Never start the engine or let it run in an enclosed area.
Engine exhaust fumes are poisonous and can result in
loss of consciousness or death in a short time.
Never drain the fuel when the engine is hot. Severe
burns may result.
FUEL TANK VENT LINE
Symptoms of a restricted fuel tank vent include the
following: collapsing fuel tank, engine miss or hesitation,
loss of engine performance or high exhaust
temperatures.
1. Remove the seats and the engine service panel.
2. Check the fuel tank vent line for signs of wear,
deterioration or damage. Replace vent line if
necessary.
3. Be sure the vent line is routed properly and secured
with cable tie(s).
NOTE
Make sure vent line is not kinked or pinched.
MAINTENANCE
To Next Page
Loading...
Need help?
General
