Engine Runs Rough
If At Slow Speed – Check:
● Idle speed and idle mixture.
● Spark plugs.
● Fuel pump pressure.
● Water or contaminants in fuel.
● Manifold vacuum leak.
● Call for assistance or see Volvo Penta authorized dealer.
If At High Speed – Check:
● Air leak on suction side of fuel system.
● Too low octane fuel.
● E20 or E85 fuel.
● Ignition system secondary circuit.
● External fuel filters.
● Water or contaminants in fuel, or water in cylinders.
● Call for assistance or see Volvo Penta authorized dealer.
Engine Noises and Vibrations
Valves (Hydraulic Lifters) – Check:
● Oil quality (dirt or water in oil).
● Oil quantity.
● Oil type and weight.
● Call for assistance or see Volvo Penta authorized dealer.
Ignition System (Ping or Knock) – Check:
● Improper tuning (see dealer).
● Cap and rotor for corrosion (see Do It Yourself manual).
● Proper octane fuel is used.
● Call for assistance or see Volvo Penta authorized dealer.
Cooling System – Check:
● Supply pump.
● Loose belts and/or pulleys.
● See section entitled Cooling System.
● Call for assistance or see Volvo Penta authorized dealer.
Mountings – Check:
● Loose, broken, or worn engine mounts.
● Loose lag screws holding mounts to stringer.
● Call for assistance or see Volvo Penta authorized dealer.
Alternator – Check:
● Loose pulley (see dealer).
● Noise from bearings (see dealer).
● Call for assistance or see Volvo Penta authorized dealer.
Sterndrive – Check:
● Failed U–joints or gimbal bearing (see dealer).
● Damaged internal drive components (see dealer).
● Worn, bent, or broken propeller hub or blades (refer to the section entitled Propeller Replacement).
● Call for assistance or see Volvo Penta authorized dealer.
Troubleshooting
47700385 05-2009 55
To Next Page
Loading...
Need help?
General
