Volvo Penta 3.0GLP-J User Manual

3.0GLP-J
ENGINE
Bore and stroke . . . . . . . . . . . . . .
Cylinders (number) . . . . . . . . . . .
Displacement . . . . . . . . . . . . . .
Firing order . . . . . . . . . . . . . . .
Full throttle operating range . . .
Idle RPM . . . . . . . . . . . . . . . . . . .
4.00 x 3.60 inches (101.60 x 91.44 mm)
4 in-line
181 Cu. In. (3.0 liters)
1 – 3 – 4 – 2
4200 – 4600 RPM
650 – 750 RPM in forward gear
FUEL SYSTEM
Carburetor . . . . . . . . . . . . . . . .
Fuel pumps . . . . . . . . . . . . . . .
Fuel filter . . . . . . . . . . . . . . . . .
Fuel type . . . . . . . . . . . . . . . . . .
Adjustable idle circuit, fixed main fuel jets, electric choke
Mechanical
Water separating 10 micron fuel filter in fuel pump
See Gasoline Requirements in this section
ELECTRICAL SYSTEM
Charging system . . . . . . . . . . .
Starter . . . . . . . . . . . . . . . . . . .
Battery size . . . . . . . . . . . . . . . .
12 volt 75 amp alternator, with internal transistorized voltage regulator
12 volt 1.7kW output, planetary reduction gear
12 volt with 360 Cold Cranking Amp (CCA) rating
Do not use a deep cycle battery as the start battery
IGNITION SYSTEM
Distributor . . . . . . . . . . . . . . . .
Ignition Timing. . . . . . . . . . . . .
Spark plugs . . . . . . . . . . . . . . .
Spark plug gap . . . . . . . . . . . . . . .
Spark plug installation torque .
Delco EST
2° ATDC
See Tune-up and Color Code Decal on engine cover or Parts Catalog
0.050 inches (1.50 mm)
20 ft. lb. (27 Nm)
COOLING SYSTEM
Raw water pump . . . . . . . . . . .
Recirculating pump . . . . . . . . . . .
Thermostat . . . . . . . . . . . . . . . .
Crankshaft mounted variable volume flexible impeller pump
Fixed impeller belt driven pump on engine
160°F (71°C)
OIL FILTER
Engine oil filter . . . . . . . . . . . . . Volvo Penta, spin-on can
OIL CAPACITY
NOTICE! Overfilling the oil can cause engine and/or sterndrive damage. We urge you to use the dipstick to check
the oil level whenever you are changing or topping up the oil.
Engine with filter . . . . . . . . . . . . .
Drive unit . . . . . . . . . . . . . . . . .
3.5 quarts (3.3 liters)
See Sterndrive: Drive Components in this section
OIL TYPE
Engine . . . . . . . . . . . . . . . . . . .
Drive unit . . . . . . . . . . . . . . . . .
Power steering fluid U.S . . . . . .
Power steering fluid non-U.S . .
See Engine Oil Specifications in this section
See Sterndrive: Drive Components in this section
Volvo Penta power steering fluid
ATF oil Dexron 2 or higher classification
OIL PRESSURE (MINIMUM)
@ 1000 RPM . . . . . . . . . . . . . .
@ 2000 RPM . . . . . . . . . . . . . .
@ 4000 RPM . . . . . . . . . . . . . .
6 PSI (41 kPa)
18 PSI (124 kPa)
24 PSI (166 kPa)
Technical Data
47700385 05-2009 97

Volvo Penta 3.0GLP-J Specifications

General

Brand	Volvo Penta
Model	3.0GLP-J
Category	Engine
Language	English