Volvo D13 User Manual

Section 01: ENGINE
PA1561 2
ILLUSTRATIONS
FIGURE 1: D13F ENGINE, ALTERNATOR SIDE (TYPICAL) ....................................................................................... 6
FIGURE 2: D13F ENGINE, TURBO SIDE (TYPICAL) ................................................................................................ 7
FIGURE 3: D13F OIL FILTERS............................................................................................................................. 9
FIGURE 4: OIL FILTER WRENCH........................................................................................................................ 10
FIGURE 5: OIL FITER REPLACEMENT................................................................................................................. 11
FIGURE 6: ENGINE OIL FILLING TUBE ................................................................................................................ 11
FIGURE 7: ENGINE OIL LEVEL DIPSTICK ............................................................................................................ 11
FIGURE 8: BELT TENSIONER VALVE.................................................................................................................. 12
FIGURE 9: ENGINE COMPARTMENT H3 COACHES (TYPICAL) ............................................................................... 14
FIGURE 10: VOLVO ENGINE POWER PLANT CRADLE INSTALLATION ..................................................................... 15
FIGURE 11: VEHICLE INTERFACE HARNESS (GENERAL APPLICATION SHOWN)...................................................... 16
FIGURE 12: DETROIT DIESEL 2007 SERIES 60 ENGINE (TYPICAL ........................................................................ 18
FIGURE 13: MOTOR CONTROL MODULE (MCM).................................................................................................. 19
FIGURE 14: CPC.............................................................................................................................................19
FIGURE 15: THE CPC COMMUNICATES OVER THE J1587 AND J1939 DATA LINKS TO THE VEHICLE ........................19
FIGURE 16: FLASHING FAULTS CODES ............................................................................................................. 21
FIGURE 17: ENGINE OIL LEVEL DIPSTICK .......................................................................................................... 39
FIGURE 18: OIL RESERVE TANK ....................................................................................................................... 39
FIGURE 19: UNDER VEHICLE VIEW ................................................................................................................... 40
FIGURE 20: ENGINE COMPARTMENT ................................................................................................................42
FIGURE 21: ENGINE COMPARTMENT H3 COACHES (TYPICAL) ............................................................................. 44
FIGURE 22: ENGINE COMPARTMENT VIP (TYPICAL)............................................................................................ 44
FIGURE 23: POWER PLANT CRADLE INSTALLATION............................................................................................ 45
FIGURE 24: ELECTRONIC FOOT PEDAL ASSEMBLY............................................................................................. 46

Volvo D13 Specifications

Engine Specifications

engine type	Diesel four cycle/in-line direct injection engine
number of cylinders	12.8 L in-line 6
operating range	1400-1800 RPM
peak power rating	435 HP (324 kW)
peak torque rating	1650 Ft-lb (2237 Nm)
low idle	600 rpm
fast idle	2150 rpm
maximum full load revolutions	1900 rpm

Oil Capacity

oil pan capacity low limit	25 quarts/24 liters
oil pan capacity high limit	34 quarts/32 liters
total engine oil capacity with filters	41 quarts/39 liters