- 54 -
8.2 Lubricants
Section
Engine crankcase
Transmission
Support of front axle
Front axle case(LH, RH)
Brake
Front, rear Bracket, Top link
holder, Top link, Clutch
release hub, Lift rod etc.
Capacity
6.4
(1.7 u.s.gal.)
58
(15.25 u.s.gal.)
4.8
(1.280 u.s.gal.)
3.5 (0.925 u.s.gal.)
0.47 (0.125 u.s.gal.)
Moderate amount
Lubricants
Engine oil : API Service CC or CD
SAE 15W - 40
Multi-grade transmission fluid
The fluid listed below are equivalent
recommendations.
Gear oil SAE 80 or SAE 90
SHELL: TELLUS 32(MINENAL)
SAE mult-purpose type grease
Maker
SHELL
Mobil
Exxon
Brand(standard)
DONAX-TD,DONAX-TM
Mobil Fluid 423
Torque Fluid 56
To prevent serious damage by hydraulic systems, use only KIOTI genuine fluid or its equivalent.
Initial operation
Frequency of check Check Notes Remarks
During this period, pay attention to the following
1. After the first 50 hours of use, change the engine oil and oil filter.
2. After the first 50 hours of use, change the transmission oil, trans-
mission oil filter and front axle case oil.
3. Sudden starting or sudden braking should be avoided.
4. When the outside temperature is low, allow the engine to warm-up
prior to operation.
5. Unusually fast driving must be avoided.
6. Reduce speed on slopes or during bad road conditions.
8.3 Maintenance Check List
NOTE :
• Make sure to stop engine completely prior to check-
ing and adjusting. (For details, please refer to the
attached check list.)
To Next Page
Loading...
Need help?
General
