Name: KTM 2014 1190 Adventure
Brand: KTM
Rating: 4 (1 reviews)

To Next Page

To Previous Page

13 SERVICE WORK ON THE CHASSIS 115

– Check the steering head bearing and adjust if necessary.

13.14 Removing the bottom triple clamp cover

202248-12

–

Remove screws

– Plug out the horn.

–

Remove the triple clamp cover

13.15 Installing the bottom triple clamp cover x

202248-13

–

Position the triple clamp cover

– Plug in the horn.

–

Mount and tighten screws

Guideline

Remaining chassis screws M6 10 Nm (7.4 lbf ft)

Default Chapter5
- Table of Contents5
1 Means of Representation10
- Symbols Used10
- Formats Used10
2 Safety Advice11
- Use Definition - Intended Use11
- Degrees of Risk and Symbols12
- Overview of Labels14
- Reporting Safety Defects18
- Noise Emission Warranty19
- Operating Noise Warning19
- Consumer Rights19
- Tampering Warning20
- Safe Operation20
- Protective Clothing21
- Work Rules21
- Environment22
- Owner's Manual22
3 Important Information23
- Warranty23
- Operating and Auxiliary Substances23
- Spare Parts, Accessories23
- Service23
- Figures24
- Customer Service24
4 View of Vehicle26
- View of Vehicle, Front Left Side (Vehicle Differs Slightly from Photo)26
- View of Vehicle, Rear Right Side (Vehicle Differs Slightly from Photo)28
5 Serial Numbers30
- Chassis Number30
- Type Label30
- Key Number31
- Engine Number32
- Fork Part Number32
- Shock Absorber Part Number33
6 Controls34
- Clutch Lever34
- Hand Brake Lever34
- Throttle Grip35
- Switch on the Left Side of the Handlebar35
- Combination Switch35
- Light Switch36
- Hazard Warning Flasher Switch36
- Menu Switch37
- Turn Signal Switch37
- Horn Button38
- Switch on the Right Side of the Handlebar38
- Emergency off Switch38
- Electric Starter Button39
- Ignition/Steering Lock39
- Immobilizer40
- Socket for Electrical Accessories40
- Opening the Filler Cap41
- Closing the Filler Cap42
- Fuel Cocks43
- Opening the Storage Compartment44
- Closing the Storage Compartment44
- Seat Lock45
- Tool Set45
- Grab Handles46
- Luggage Rack Plate46
- Passenger Footrests47
- Shift Lever47
- Side Stand48
- Center Stand (Option: Center Stand)49
7 Combination Instrument50
- Overview50
- Activation and Test50
- Matrix Display51
- Segment Display51
- Indicator Lamps52
- Message on the Matrix Display53
- Shift Warning Light54
- Service Display55
- Matrix Display Menu55
- Favorites55
- Trip 156
- Trip 256
- General Info57
- TPMS" (Optional)57
- Set Favorites58
- Settings58
- Warnings59
- Heat Grip" (Optional)59
- Mtc/Abs60
- Load60
- Damping61
- Drive Mode61
- Menu Overview62
- Language64
- Distance64
- Temp65
- Volume65
- Pressure66
- Clock/Date66
- Fuel Cons67
- Drl67
- Shift Light68
- Quick Shift68
- Heat Grips69
8 Ergonomics70
- Adjusting the Driver's Seat70
- Handlebar Position71
- Adjusting the Handlebar Position71
- Adjusting the Wind Shield72
- Adjusting the Basic Setting of the Clutch Lever74
- Adjusting the Basic Position of the Hand Brake Lever74
- Rider Footrests75
- Adjusting the Footrests75
- Foot Brake Lever77
- Adjusting the Basic Position of the Foot Brake Lever77
- Checking the Basic Position of the Shift Lever79
- Adjusting the Basic Position of the Shift Lever79
9 Preparing for Use81
- Advice on First Use81
- Running in the Engine82
- Loading the Vehicle83
10 Riding Instructions85
- Checks and Maintenance Measures When Preparing for Use85
- Starting86
- Starting off87
- Shifting, Riding87
- Applying the Brakes91
- Stopping, Parking93
- Transport95
- Refueling96
11 Service Schedule98
- Additional Information98
- Required Work98
- Recommended Work101
12 Suspension Setting102
- Damping" (Option: with EDS)102
- Load" (Option: with EDS)102
- Fork/Shock Absorber103
- Service Work on the Chassis104
- Raising the Vehicle with the Center Stand (Option: Center Stand)104
- Removing the Vehicle from the Center Stand (Option: Center Stand)104
- Removing the Passenger Seat105
- Mounting the Passenger Seat106
- Removing the Driver's Seat106
- Mounting the Driver's Seat107
- Checking for Chain Dirt107
- Cleaning the Chain108
- Checking the Chain Tension109
- Adjusting the Chain Tension110
- Checking the Chain, Rear Sprocket and Engine Sprocket112
- Checking/Rectifying the Fluid Level of the Hydraulic Clutch115
- Checking the Steering Head Bearing Play116
- Removing the Bottom Triple Clamp Cover117
- Installing the Bottom Triple Clamp Cover117
- Removing the Front Side Cover118
- Installing the Front Side Cover119
- Removing the Mask Spoiler120
- Installing the Mask Spoiler123
- Removing the Front Fender125
- Installing the Front Fender126
- Removing the Tank Cover126
- Installing the Tank Cover128
- Removing the Wind Shield129
- Installing the Wind Shield130
14 Brake System131
- Abs/Antilock Brake System131
- Checking the Brake Discs133
- Checking the Brake Fluid Level of the Front Brake134
- Adding Front Brake Fluid134
- Checking the Front Brake Linings136
- Checking the Rear Brake Fluid Level137
- Adding Rear Brake Fluid X138
- Checking the Rear Brake Linings140
15 Wheels, Tires141
- Removing the Front Wheel141
- Installing the Front Wheel143
- Removing the Rear Wheel145
- Installing the Rear Wheel147
- Checking the Rear Hub Rubber Dampers149
- Checking the Tire Condition151
- Checking the Tire Air Pressure152
- Checking Spoke Tension153
16 Electrical System155
- Daytime Running Light155
- Removing the Battery155
- Installing the Battery157
- Recharging the Battery159
- Changing the Main Fuse163
- Changing the Fuses in the Fuse Box165
- Removing the Headlight Mask with the Headlight167
- Refitting the Headlight Mask with the Headlight169
- Changing the Low Beam Bulb170
- Changing the High Beam Bulb171
- Changing the Turn Signal Bulb173
- Checking the Headlight Setting174
- Adjusting the Headlight Range175
- Activating/Deactivating the Ignition Key176
17 Cooling System181
- Checking the Coolant Level in the Compensating Tank181
- Correcting the Coolant Level in the Compensating Tank182
18 Engine Tuning184
- Drive Mode184
- Mtc/Motorcycle Traction Control184
19 Service Work on the Engine186
- Checking the Engine Oil Level186
- Changing the Engine Oil and Filter, Cleaning the Oil Screens187
- Adding Engine Oil191
20 Cleaning, Care194
- Cleaning Motorcycle194
- Checks and Maintenance Steps for Winter Operation196
21 Storage198
- Preparing for Use after Storage199
22 Troubleshooting200
23 Technical Data202
- Engine202
- Engine Tightening Torques203
- Capacities206
- Engine Oil206
- Coolant207
- Fuel207
- Chassis207
- Option: with EDS207
- Electrical System209
- Option: with EDS209
- Tires210
- Fork210
- Option: with EDS210
- Shock Absorber210
- Chassis Tightening Torques211
24 Substances215
25 Auxiliary Substances219
26 Standards221
- Index222

KTM 2014 1190 Adventure User Manual

Table of Contents

Questions and Answers:

KTM 2014 1190 Adventure Specifications

Related product manuals

Brand	KTM
Model	2014 1190 Adventure
Category	Motorcycle
Language	English