Kubota SSV65 User Manual

1. If the hoses or pipes of the air-conditioner are
swollen, hard or cracked, replace them.
Consult your local KUBOTA dealer for replacing the
pipes and hoses of the air-conditioner.
7. Replacing the closed breather
related rubber piping
Consult your local KUBOTA dealer for replacing the
closed-breather-related-rubber-piping.
8. Replacing the diesel-particulate-
filter (DPF) differential pressure
sensor rubber piping (front and
back)
Consult your local KUBOTA dealer for the DPF-
differential-pressure-sensor-rubber-piping (front and
back).
9. Replacing the suction pipe
downstream the AFS (air-flow-
sensor)
Consult your local KUBOTA dealer for replacing the
suction pipe downstream the AFS.
10. Replacing the boost sensor
pressure rubber piping
Consult your local KUBOTA dealer for replacing the
boost-sensor-pressure-rubber-piping.
11. Replacing the EGR cooler hose
Consult your local KUBOTA dealer for replacing the
EGR-cooler-hose.
SERVICING AS REQUIRED
1. Checking the amount of
refrigerant gas
WARNING
To avoid personal injury or death:
• Liquid contact with eyes or skin may cause
frostbite.
• In the event of a leakage, wear safety goggles.
Escaping refrigerant can cause severe injuries
to eyes.
• In contact with a flame, R134a refrigerant emits
a toxic gas.
• Do not disconnect any part of the refrigeration
circuit of the air-conditioning system. Consult
your local KUBOTA dealer for assistance and
service of refrigerant.
If the air-conditioner performance is reduced, check the
following points 1.-2.
1. Air-conditioner condenser is clogged.
2. Air-conditioner belt is loosened.
If there is nothing unusual with the above points, a
shortage of refrigerant is possible. Too short refrigerant
may cause a poor performance of the air-conditioner.
Consult your local KUBOTA dealer for servicing and
replenishment.
2. Draining the water separator in
case warning against water of the
fuel filter
1. If the error code [E:9120] of the water separator
appears on the meter panel, immediately drain the
water separator according to the detailed procedure
in Draining the water separator on page 85.
IMPORTANT :
• If you don't drain the water separator
immediately after the alarm, the engine may
be seriously damaged.
• Without the water separator drained, the
cleaning efficiency of the DPF (3000 hours)
will be reduced and the DPF longevity will be
shorter than expected.
3. Purging of the fuel system
1. Fill up the machine with fuel.
2. Turn the starter key to the [RUN] position.
The fuel system will automatically be purged of air
within one minute.
(1) Starter switch
(A) STOP
(B) RUN
(C) START
BIENNIAL SERVICING MAINTENANCE
SSV65,SSV75
105

Kubota SSV65 Specifications

General

Brand	Kubota
Model	SSV65
Category	Utility Vehicle
Language	English