MAINTENANCE
2.20
2004 Four Stroke PWC Service Manual
Gasoline Safety
W ARNING
Gasoline is highly flammable and explosive under certain conditions.
♦ Always exercise extreme caution whenever handling gasoline.
♦ Always refuel with the engine stopped and outdoors or in a well ventilated area.
♦ Do not smoke or allow open flames or sparks in or near the area where refueling is performed or where
gasoline is stored.
♦ Do not over fill the tank. (Do not fill the tank neck.)
♦ If you get gasoline on your skin or clothing, immediately wash it off with soap and water and change
clothing.
♦ Never start the engine or let it run in an enclosed area. Gasoline powered engine exhaust fumes are
poisonous and can cause loss of consciousness and death in a short time.
♦ Shut off fuel valve (if applicable) whenever the watercraft is stored, parked, or transported.
Fuel Lines / Vent Lines
1. Check fuel lines and vent lines for signs of wear, deterioration, damage or leakage. Replace if necessary.
Ensure that clamps are tight.
2. Be sure all lines are routed properly and secured with cable ties away from any moving parts.
CAUTION:
Make sure lines are not kinked or pinched.
Water Separating F ilter
The water separating filter requires no maintenance.
In--Line Fuel Filter
The inline fuel filter is located in front of the fuel tank and
is connected to the fuel supply hose. Verify arrow points
towards the engine (downstream) when installing new fil-
ter.
To Next Page
Loading...
Need help?
General