Polaris RZR XP 1000 2014 Service Manual

11.4
9926816 R07 - 2014-2016 RZR XP 1000 / XP4 1000 Service Manual
© Copyright Polaris Industries Inc.
GENERAL INFORMATION
SPECIAL TOOLS
PART NUMBER TOOL DESCRIPTION
PV-43568
Fluke™ 77 Digital Multimeter
PV-43526 Connector Test Kit
2870630
Timing Light
PU-50338
Battery Hydrometer
2460761 Hall Effect Sensor Probe Harness
2871745
Static Timing Light Harness
PU-50296
Battery Conductance Analyzer
(MDX-610P)
PU-49466
Relay Bypass
-
Digital Wrench® (see Chapter 4 –
DIGITAL WRENCH® OPERATION,
page )
Bosch Automotive Service Solutions: 1-800-345-2233
or http://polaris.service-solutions.com/
TORQUE SPECIFICATIONS
ITEM
TORQUE
Coolant Temperature
Sensor
17 ft-lb (23 Nm)
Starter Mounting
Fasteners
7 ft-lb (10 Nm)
Oxygen Sensor 13 ft-lb (18 Nm)
ELECTRICAL SERVICE NOTES
Keep the following notes in mind when diagnosing an
electrical problem:
• All EFI component information and diagnostic testing
procedures are located in the Fuel System chapter.
• Always refer to Digital Wrench when diagnosing and
diagnostic trouble code.
• Refer to wiring diagram for stator and electrical
component resistance specifications.
• When measuring resistance of a component that has a
resistance value under 10 Ohms, remember to
subtract meter lead resistance from the reading.
Connect the leads together and record the resistance.
The resistance of the component is equal to tested
value minus the lead resistance.
• Become familiar with the operation of your meter. Be
sure leads are in the proper jack for the test being
performed (i.e. 10A jack for current readings). Refer to
the Owner’s Manual included with your meter for more
information.
• Voltage, amperage, and resistance values included in
this manual are obtained with a Fluke™ 77 Digital
Multimeter (PV-43568). This meter is used when
diagnosing electrical problems. Readings obtained
with other meters may differ.
• Pay attention to the prefix on the multimeter reading
(K, M, etc.) and the position of the decimal point.
• For resistance readings, isolate the component to be
tested. Disconnect it from the wiring harness or power
supply.
• Most electrical issues are related to damaged wiring.
Fully test wiring before replacing any components.
UNDER-DASH COMPONENTS
The following switches and components can be
accessed underneath the instrument / dash panel:
• Speedometer
• AWD Switch
• Headlamp Switch
• 12 Vdc Accessory Power Point
• Ignition Switch
• LED Ambiance Light
ELECTRICAL

Polaris RZR XP 1000 2014 Specifications

General

Brand	Polaris
Model	RZR XP 1000 2014
Category	Offroad Vehicle
Language	English