JUKI LU-2818-7 User Manual

– 12 –
WARNING :
1. Do not connect the power plug until the lubrication has been completed so as to prevent accidents
due to abrupt start of the sewing machine.
2. To prevent the occurrence of an inammation or rash, immediately wash the related portions if oil
adheres to your eyes or other parts of your body.
3. If oil is mistakenly swallowed, diarrhea or vomitting may occur. Put oil in a place where children
cannot reach.
1. When using a new sewing machine for the rst time or using the sewing machine which has not
been used for a long time, run in the sewing machine at a sewing speed of 1,000 sti/min or less and
check the oil quantity in the hook before use.
If the quantity of oil in the hook is insufcient, adjust the quantity of oil by turning the oil quantity
adjusting screw counterclockwise to ensure that the oil quantity in the hook is adequate. After that,
adjust the quantity of oil to the adequate one. (Refer to "■ Adjusting the oil quantity in the hook" p.13.)
2. For the oil for hook lubrication, purchase JUKI NEW DEFRIX OIL No. 1 (Part No. : MDFRX1600C0) or
JUKI MACHINE OIL #7 (Part No. : MML007600CA).
3. Be sure to lubricate clean oil.
■ Lubrication procedure
Fill the oil tank with oil before operating the sewing
machine.
1) Fill the oil tank with JUKI NEW DEFRIX OIL
No.1 (Part No. : MDFRX1600C0) or JUKI MA-
CHINE OIL #7 (Part No. : MML007600CA) using
the oiler supplied with the machine from section
C
.
2) Fill the oil tank with the oil until the top end of
oil amount indicating rod
❷
comes between the
upper engraved marker line
A
and the lower
engraved marker line
B
of oil amount indicating
window
❶
.
If the oil is lled excessively, it will leak from the
air vent hole in the oil tank or proper lubrication
will be not performed. In addition, when the oil
is vigorously lled, it may overow from the oil
hole. So, be careful.
3) When you operate the sewing machine, rell
oil if the top end of oil amount indicating rod
❷
comes down to the lower engraved marker line
B
of oil amount indicating window
❶
.
3. PREPARATION OF THE SEWING MACHINE
3-1. Lubrication
C
❶
B
A
❷
LU-2818-7, LU-2868-7
LU-2810, LU-2810-7
LU-2860, LU-2860-7
C

JUKI LU-2818-7 Specifications

General

Brand	JUKI
Model	LU-2818-7
Category	Sewing Machine
Language	English