Kenmore 106.89599100 User Manual

76 pages

To Next Page

To Next Page

To Previous Page

To Previous Page

Page #7 background image

Loading...

Page #7 background image

1-4

n

GENERAL INFORMATION

Model Numbers

KENMORE

106.89592100

106.89599100

106.89593100

106.89553100

*Introductory Models

KENMORE 2013 NEW DESIGN ICE MAKERS WITH

FILTER

Table of Contents

Table of Contents3
Section 1 - General Information4
Ice Maker Safety5
Important Safety Instructions5
Model Numbers7
Model & Serial Number Labal8
Tech Sheet Location8
Dimensions9
Section 2 - Installation and Operating Instructions10
Protection Agreements10
Troubleshooting10
Table of Contents10
Warranty10
Ice Maker Safety10
Ice Maker Use10
Ice Maker Care10
- Protection Agreements12
- Electrical Requirements15
- Location Requirements15
- Cleaning before Use15
- Tools Needed16
- Water Supply Requirements16
- Reverse Osmosis Water Supply16
- Connect Water Supply16
- Drain Pump Installation17
- If Ice Maker Is Currently Installed17
- Rear View17
- Kit Contents17
- Water Supply Line18
- Drain Tube18
- Parts Location18
- Rear Panel18
- Drain Pump Mounting Tab Slot19
- Drain Pump Installed19
- Vent Tube19
- Connecting the Drain20
Performance Data Sheet20
- Gravity Drain System20
- Drain Pump System20
- Drain Connection20
- Door Reversal21
- Door Stop and End Cap Reversal21
- Reverse Hinges22
- Replace Door22
- Reverse Door Catch22
- Leveling23
- Water Filtration System23
- Install the Water Filter23
- Ice Maker Use24
- How Your Ice Maker Works24
- The Water Filter Status Light24
- Replace the Water Filter24
- Door Ajar Alarm25
- Normal Sounds25
- Acceler-Ice Mode25
- Using the Controls25
- Ice Maker Care26
- Exterior Surfaces26
- Ice Maker System26
- Condenser26
- Interior Compartments27
- Vacation and Moving Care28
- To Shut down the Ice Maker28
- Troubleshooting29
- Ice Maker Operation29
- Ice Production30
- Ice Quality30
- Plumbing Problems31
- Performance Data Sheet31
- Accessories31
Refrigeration System33
SECTION 3 - Theory of OPERATION33
Operating System33
Water System33
- Operating Systems34
- Refrigeration System34
- EXAMPLE of Ice Maker Sealed System35
- Water System36
Electrical System36
Operational Modes37
- Harvest Mode38
- Clean Mode38
- Diagnostic Mode38
Section 4 - Component Access39
Front Grille Components40
- Leveling Legs40
- Removing the Water Valve40
- Door Gasket Service41
- Ice bin Door Removal41
- Door Removal/Reversal41
Ice bin Components41
- Removing Reservoir Cover42
- Heater Grid Removal42
- Removing the bin Thermistor42
- Accessing Ice bin Electrical Connections43
- Removing Reservoir and Pumps43
- Removing Drain Pump44
- Removing Water Level Sensor44
- Removing Recirculation Pump44
Ice Maker Top Components45
- Removing Top45
- Accessing the Control Compartment46
- Removing Transformer46
- Removing User Interface Board46
- Removing Main Control Board47
- Fan Inductor and Thermistor48
- Accessing Machine Compartments48
Machine Compartment Components48
- Condensate Pump Removal49
- Raising Cabinet to Access Components49
Section 5 - Diagnostics and Troubleshooting51
Safety52
Service Diagnostics53
- Entering Diagnostic Mode53
- Flush Mode56
- Freeze Cycle56
- Clean Cycle57
- Compressor Resistances58
Troubleshooting58
- Wiring Schematic59
- Voltage Test Point Chart60
- Locating Test Points in Control Compartment61
- Main Board Connector Identification61
- Evaporator Thermistor62
- Concealed Reed Switch62
- Pump Kit63
SECTION 6 - REFRIGERANT Recovery and CHARGING PROCEDURES64
Representitive Examples of Equipment, Tools and Supplies64
Equipment, Tools and Supplies64
Key Components64
Phase One: Initial Hook up64
Phase Two: Refrigerant Recovery64
- Sealed System Repair65
- Equipment, Tools and Supplies66
- Key Components67
- Initial Hook up68
- Refrigerant Recovery70
Phase Three: Make Repairs71
- Evacuation72
- Charging74

Questions and Answers:

Need help?

Do you have a question about the Kenmore 106.89599100 and is the answer not in the manual?

Kenmore 106.89599100 Specifications

General

Brand	Kenmore
Model	106.89599100
Category	Ice Maker
Language	English

Related product manuals

Preview: Kenmore 106.89592100

Kenmore 106.89592100

Kenmore 106.89553100

Preview: Kenmore 106.8955 Series

Kenmore 106.8955 Series

Kenmore Ice Maker