Home
Kubota
Utility Vehicle
RTV-X1100C
Kubota RTV-X1100C User Manual
5
of 1
of 1 rating
114 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
57
PERIODIC SERVICE
B
Checking Joint Boot
1.
Check to see if the joint b
oots are not damaged.
2.
If the boots are cuts, cracked or shows signs of
deterioration, consult your local KUBOTA Dealer.
[Front]
(1) Joint boot
(2) Front drive shaf
t
(3) Tie rod
(1) Joint boot
(2) Front drive shaf
t
(1) Joint boot
(2) Rear drive shaft
(1) Joint boot
(A) Rear stabilizer
(1) Joint boot
(2) Drive shaft
78
80
Table of Contents
Default Chapter
3
Control Symbols
3
Safety First
4
Table of Contents
5
Safe Operation
23
Servicing of Vehicle
23
Specifications
25
Specification Table
25
Traveling Speeds
26
Vehicle Limitations
27
Instrument Panel and Controls
28
Location of Parts
28
Pre-Operation Check
32
Daily Check
32
Operating the Engine
33
Starting the Engine
33
Cold Weather Starting
35
Engine Hand Throttle
35
Block Heater
35
Stopping the Engine
36
Warming up
36
Warm-Up Transmission Oil in the Low Temperature Range
36
Jump Starting
36
Operating the Vehicle
38
Operating New Vehicle
38
Do Not Operate the Vehicle at Full Speed for the First 50 Hours
38
Changing Lubricating Oil for New Vehicles
38
Starting
38
Locking and Unlocking the Door
38
Seat Belt
39
Tilt Steering Wheel
39
Seat Slide Lever
39
Head Light Switch
40
Hazard Light Switch
40
Turn Signal Light Switch
40
Horn Button
41
Work Light (Front)
41
Work Light (Rear)
41
Brake Pedal
42
Range Gear Shift Lever
42
4WD Lever
43
Parking Brake Lever
43
Speed Control Pedal
44
Contents
44
Stopping
44
Check During Driving
44
Immediately Stop the Engine if
44
Easy Checker(TM)
44
Fuel Gauge
45
Coolant Temperature Gauge
45
Hourmeter and Odometer
46
Speedometer
46
Parking
47
Parking Brake Lever
47
Accessory
47
(1) 12V Electric Outlet
47
Utility Box
47
Glove Box (Std.) and Glove Box Cover (if Equipped)
48
Operating Techniques
48
Differential Lock
48
Directions for Use of Power Steering
49
Unfamiliar Terrain
49
Driving in Reverse
49
Driving in "4WD
50
Turning the Vehicle
50
Hills
51
Traversing Hillsides
51
Sliding and Skidding
51
Driving through Water
52
Operating Hand Throttle
52
Stationary Hydraulic Outlet
52
Cargo Bed
53
General Caution
53
Max. Cargo Load
53
Cargo Bed Tailgate
55
Raising and Lowering the Cargo Bed
55
Raising and Lowering the Cargo Bed [Without Hydraulic Dump]
57
Hydraulic Outlet
58
Hydraulic Outlet Lever
58
Hydraulic Outlet Valve Coupler Connecting and Disconnecting
59
Tires and Wheels
60
Tires
60
Inflation Pressure
60
Tire Type and Use
60
Wheels
61
Shock Absorbers
61
Shock Absorber Spring Adjustment
61
Towing and Transporting
62
Rear Trailer Hitch
62
Front Trailer Hitch
62
Winch Mount Bracket
63
Transport the Vehicle Safely
63
Maintenance
64
Service Intervals
64
Lubricants, Fuel and Coolant
67
Periodic Service
71
How to Open the Hood and Tilt the Seat
71
Hood
71
Seat
71
How to Raise the Cargo Bed
72
Raising and Lowering the Cargo Bed [If Equipped with Hydraulic Dump]
72
Raising and Lowering the Cargo Bed [Without Hydraulic Dump]
72
Jack-Up Point
72
Front End
72
Rear End
73
Daily Check
73
Walk Around Inspection
73
Checking Around Engine
73
Checking and Refueling
74
Checking Engine Oil Level
74
Checking Transmission Fluid Level
75
Checking Hydraulic Oil Tank Level
75
Checking Coolant Level
76
Cleaning Radiator Screen
76
Cleaning Oil Cooler Net
77
Checking Brake Fluid Level
77
Checking Brake Pedal
78
Checking Parking Brake
78
Checking Easy Checker(TM)
78
Checking Head Light, Turn Signal Light (if Equipped) Etc
78
Checking Seat Belt and ROPS
78
Checking Joint Boot
79
Checking Tire Inflation Pressure
80
Checking Backup Beeper
80
Every 50 Hours
81
Greasing
81
Checking Engine Start System
82
Every 100 Hours
83
Checking VHT Neutral Spring
83
Checking VHT Pressure Release
83
Checking Wheel Fastener Torque
84
Cleaning Air Cleaner Primary Element
84
Adjusting Alternator Belt Tension
85
Checking Fuel Line and Fuel Filter
85
Checking Battery Condition
86
Adjusting Toe-In
88
Cleaning Muffler
89
Every 200 Hours
90
Adjusting Parking Brake
90
Replacing Engine Oil Filter
91
Changing Engine Oil
91
Replacing Transmission Oil Filter [VHT]
92
Replacing Transmission Oil Filter [SUCTION]
93
Changing Hydraulic Tank Oil
93
Checking Brake Pedal
94
Checking Brake Hose and Pipe
95
Checking Front Brake Case
95
Checking Brake Light Switch
96
Checking Radiator Hose, Pipe and Clamp
96
Checking Intake Air Line
97
Checking Hydraulic Oil Line
98
Contents
93
Every 300 Hours
99
Checking Tire
99
Every 400 Hours
100
Changing Front Knuckle Case Oil
100
Changing Transmission Fluid
100
Changing Front Axle Case Oil
101
Every 500 Hours
102
Replacing Fuel Filter
102
Every 800 Hours
102
Adjusting Engine Valve Clearance
102
Every 1500 Hours
102
Checking Fuel Injection Nozzle Injection Pressure
102
Every 3000 Hours
102
Checking Injection Pump
102
Every 1 Year
102
Replacing Air Cleaner Primary Element and Secondary Element
102
Anti-Freeze
103
Replacing Radiator Hose (Water Pipes)
104
Replacing Hydraulic Oil Line
104
Replacing Fuel Hose
104
Replacing Engine Breather Hose
104
Replacing Brake Master Cylinder (Inner Parts)
104
Replacing Front Brake Seal
104
Replacing Rear Brake Cylinder Seal
104
Replacing Intake Air Line
104
Replacing Air Conditioner Pipe and Hose
104
Every 4 Years
105
Replacing Brake Hose
105
Service as Required
105
Bleeding Fuel System
105
Cleaning Around Engine
105
Replacing Fuse
105
Protected Circuit
106
Replacing Slow-Blow Fuses
107
Replacing Light Bulb
107
Checking Hydraulic Tank Suction Strainer
107
Storage
108
Vehicle Storage
108
Removing the Vehicle from Storage
108
Troubleshooting
109
Engine Troubleshooting
109
Battery Troubleshooting
110
Machine Troubleshooting
111
Options
112
Index
113
5
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Kubota RTV-X1100C and is the answer not in the manual?
Ask a question
Kubota RTV-X1100C Specifications
General
Brand
Kubota
Model
RTV-X1100C
Category
Utility Vehicle
Language
English
Related product manuals
Kubota RTV-X1120D
114 pages
Kubota RTV-X
114 pages
Kubota RTV-X900
114 pages
Kubota RTV-X900G
126 pages
Kubota SIDEKICK RTV-XG850
99 pages
Kubota RTV 900
4 pages
Kubota RTV900
108 pages
Kubota RTV520
96 pages
Kubota RTV1100
44 pages
Kubota RTV1140CPX
379 pages
Kubota WSM RTV500
31 pages
Kubota RTV1140 CPX
104 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
